Rust

Jump to: navigation, search
m (Reverted edits by 74.231.24.2 (Talk); changed back to last version by Jon)
Line 1: Line 1:
[http://murasaki-neko.freehostia.com/data/men-in2/ men in foto] [http://ruefrost.freehostia.com/styles/auto-noleggio81.htm auto noleggio villasimius] [http://jessunit.freehostia.com/lib/tromba-con/ tromba con donne] [http://kieloid.freehostia.com/description/krypton-egg.htm krypton egg] [http://kieloid.freehostia.com/description/novita-e.htm novita e informazioni via sms gratuiti] [http://crackoon.freehostia.com/resources/auto-toshiba.htm auto toshiba] [http://tatakaroli.freehostia.com/blog/jebacina.htm jebacina] [http://outeniqua.freehostia.com/blog/gail-mckenna/ gail mckenna] [http://chrome-newfie.freehostia.com/new/deore-xt.htm deore xt] [http://chrome-newfie.freehostia.com/new/kuwait-al.htm kuwait al] [http://xenajedi.freehostia.com/directory/barche-r.htm barche r c  motoscafi] [http://murasaki-neko.freehostia.com/data/mercedes-it/ mercedes it] [http://kieloid.freehostia.com/description/hp-officejet14.htm hp officejet v40] [http://wellhaveaball.freehostia.com/new/lisola-di/ lisola di montecristo] [http://ruefrost.freehostia.com/styles/sussidio-inps.htm sussidio inps per maternita] [http://disext.freehostia.com/description/hetian.htm hetian] [http://makesomelove.freehostia.com/web/televisori-samsung6/ televisori samsung 28] [http://xenajedi.freehostia.com/directory/majestic-scd2.htm majestic scd autoradio] [http://makesomelove.freehostia.com/web/canon-eos26/ canon eos custodia] [http://miraxcorran.freehostia.com/description/candy-dolce/ candy dolce candy] [http://wellhaveaball.freehostia.com/new/giornali-scritti1/ giornali scritti in epoca atica giolitti] [http://tatakaroli.freehostia.com/blog/virgin-teen.htm virgin teen] [http://miraxcorran.freehostia.com/description/la-rivolta4/ la rivolta dell apache] [http://paleshadow.freehostia.com/content/lavoro-a9/ lavoro a domicilio campania] [http://machi-neko.freehostia.com/blog/nuova-porsche3/ nuova porsche carrera benzina auto nuove] [http://miraxcorran.freehostia.com/description/mina-se/ mina se telefonando] [http://outeniqua.freehostia.com/blog/motori-di3/ motori di ricerca hard] [http://tatakaroli.freehostia.com/blog/collane-pietra.htm collane pietra dura] [http://ms-beeblebrox.freehostia.com/clink/ clink] [http://wellhaveaball.freehostia.com/new/teatro-roma/ teatro roma] [http://junkland-red.freehostia.com/directory/metul/ metul] [http://disext.freehostia.com/description/gloria-estefan6.htm gloria estefan conga] [http://wellhaveaball.freehostia.com/new/gdje-si/ gdje si sad] [http://kieloid.freehostia.com/description/chiesa.htm chiesa] [http://crackoon.freehostia.com/resources/samsonite-trekking.htm samsonite trekking 100] [http://makesomelove.freehostia.com/web/lebt-denn5/ lebt denn der alte holzmichl] [http://outeniqua.freehostia.com/blog/presidenti-di1/ presidenti di commissione esami di stato] [http://juli8.freehostia.com/html/salvatore-martinez.htm salvatore martinez] [http://ruefrost.freehostia.com/styles/dolce-memole.htm dolce memole] [http://wellhaveaball.freehostia.com/new/procioni/ procioni] [http://tatakaroli.freehostia.com/blog/noma.htm noma] [http://juli8.freehostia.com/html/nere-singole.htm nere singole] [http://outeniqua.freehostia.com/blog/my-inmortal/ my inmortal evanescens] [http://chrome-newfie.freehostia.com/new/www-univision.htm www univision] [http://assharp.freehostia.com/lib/gemini-astronautica/ gemini (astronautica)] [http://murasaki-neko.freehostia.com/data/tomb-radier/ tomb radier] [http://outeniqua.freehostia.com/blog/immagini-di33/ immagini di macchine da corsa] [http://chrome-newfie.freehostia.com/new/ma-ai1.htm ma ai ai hii] [http://miraxcorran.freehostia.com/description/auto-friuli1/ auto friuli venezia giulia] [http://juli8.freehostia.com/html/audi-s7.htm audi s4 27] [http://kieloid.freehostia.com/description/script-mirc.htm script mirc] [http://machi-neko.freehostia.com/blog/doccia-da/ doccia da giardino] [http://chrome-newfie.freehostia.com/new/amor-calienti.htm amor calienti] [http://assharp.freehostia.com/lib/km-nissan3/ km0 nissan x trail auto km 0] [http://murasaki-neko.freehostia.com/data/dal-lago1/ dal lago filiberto] [http://kieloid.freehostia.com/description/neuroanestesia-pediatrica.htm neuroanestesia pediatrica] [http://juli8.freehostia.com/html/powerbook-1.htm powerbook 15 apple portatili] [http://chrome-newfie.freehostia.com/new/peter-alexsander.htm peter alexsander de] [http://machi-neko.freehostia.com/blog/consulente-mutuo/ consulente mutuo] [http://ruefrost.freehostia.com/styles/elastici-pesca.htm elastici pesca] [http://gitanna.freehostia.com/la-primula2.htm la primula nera] [http://tatakaroli.freehostia.com/blog/qbo.htm qbo] [http://gitanna.freehostia.com/mar-rosso5.htm mar rosso hurghada] [http://disext.freehostia.com/description/derryl-hanna.htm derryl hanna] [http://wellhaveaball.freehostia.com/new/serial-norton/ serial norton 2004] [http://kieloid.freehostia.com/description/wireless-mb.htm wireless 108mb access point dwl2100ap] [http://ruefrost.freehostia.com/styles/morgan-heritage.htm morgan heritage] [http://ruefrost.freehostia.com/styles/asics-gel1.htm asics gel rocket] [http://tatakaroli.freehostia.com/blog/giochi-per29.htm giochi per pc da scaricare gratis] [http://ruefrost.freehostia.com/styles/vendita-uccelli.htm vendita uccelli torino] [http://gitanna.freehostia.com/rs-4.htm rs 50 chesterfield] [http://machi-neko.freehostia.com/blog/robbie-willimas/ robbie willimas] [http://wellhaveaball.freehostia.com/new/despues-de/ despues de ti] [http://crackoon.freehostia.com/resources/fan-towers.htm fan towers] [http://assharp.freehostia.com/lib/infermiere-porche/ infermiere porche free] [http://outeniqua.freehostia.com/blog/waiting-for/ waiting for you love] [http://makesomelove.freehostia.com/web/roberto-michels/ roberto michels libri] [http://ruefrost.freehostia.com/styles/per-pane.htm per pane] [http://juli8.freehostia.com/html/www-lahora.htm www lahora de tu muerte com] [http://miraxcorran.freehostia.com/description/watch-porn/ watch porn movie online] [http://paleshadow.freehostia.com/content/abbigliamento-gucci/ abbigliamento gucci] [http://disext.freehostia.com/description/satira-letteratura.htm satira letteratura italiana 900] [http://chrome-newfie.freehostia.com/new/logger-con.htm logger con progdvb] [http://tatakaroli.freehostia.com/blog/la-squadriglia.htm la squadriglia dei falchi rossi] [http://chrome-newfie.freehostia.com/new/volvo-it.htm volvo it] [http://paleshadow.freehostia.com/content/iesi-istituto/ iesi istituto europeo per lo sviluppo delle impres] [http://miraxcorran.freehostia.com/description/struzzi/ struzzi] [http://chrome-newfie.freehostia.com/new/vendita-cellulare.htm vendita cellulare lg] [http://paleshadow.freehostia.com/content/destin/ destin] [http://gitanna.freehostia.com/sito-inwind.htm sito inwind] [http://disext.freehostia.com/description/autunno-inverno.htm autunno inverno diesel maglieria donna] [http://assharp.freehostia.com/lib/immagini-di34/ immagini di gioco per blade dancer] [http://juli8.freehostia.com/html/laura-antonelli.htm laura antonelli] [http://kieloid.freehostia.com/description/veronica-vanoza.htm veronica vanoza] [http://chrome-newfie.freehostia.com/new/trasporti-su.htm trasporti su rotaie] [http://outeniqua.freehostia.com/blog/chris-potter/ chris potter] [http://machi-neko.freehostia.com/blog/visual-v1/ visual v7] [http://kieloid.freehostia.com/description/hyundai-coupe5.htm hyundai coupe 1 6 2000] [http://outeniqua.freehostia.com/blog/polo-prada/ polo prada donna] [http://jessunit.freehostia.com/lib/la-valle8/ la valle del minotauro] [http://resident-raptor.freehostia.com/web/giochi-e.htm giochi e scommesse] [http://sillyrabbittrix.freehostia.com/content/modem-adsl86/ modem adsl hamlet esterno usb] [http://deathsynthe2000.freehostia.com/articles/epson-fx.htm epson fx2190] [http://orencat.freehostia.com/library/bastardo-dentro/ bastardo dentro com] [http://mevans86.freehostia.com/seconda-prova/ seconda prova esami di stato itc 2004] [http://jmarzluff.freehostia.com/html/captain-commando.htm captain commando] [http://a-l-l-o-y.freehostia.com/maca/ maca] [http://eosneo2501.freehostia.com/cat-mania.htm cat mania] [http://jmarzluff.freehostia.com/html/ciofu.htm ciofu] [http://big-dreamer24.freehostia.com/lib/unidos-do.htm unidos do caralho a quatro] [http://cetki.freehostia.com/html/lacie-usb.htm lacie usb 500 gb] [http://death-stab.freehostia.com/data/grossi-cazzi3/ grossi cazzi gay] [http://resident-raptor.freehostia.com/web/nino-dalesio.htm nino dalesio] [http://orencat.freehostia.com/library/email-antivirus/ email antivirus] [http://death-stab.freehostia.com/data/prestito-schio/ prestito schio] [http://aspiringlygodly.freehostia.com/articles/lucia-galeone/ lucia galeone] [http://semen-serpent.freehostia.com/data/la-grande67.htm la grande persecuzione] [http://maniak-sk.freehostia.com/data/dott-tosti/ dott tosti] [http://jmarzluff.freehostia.com/html/centro-benessere31.htm centro benessere] [http://miss-snoopy25.freehostia.com/new/memoria-ram/ memoria ram sdr] [http://despotic-intern.freehostia.com/blog/multisplit-pompa/ multisplit pompa di calore] [http://adadem.freehostia.com/html/alfa-romeo115/ alfa romeo 147 19 jtd] [http://chibi-evil.freehostia.com/small/asolta-pooh.htm asolta pooh] [http://irremedy.freehostia.com/view/punto-km/ punto km 0] [http://death-stab.freehostia.com/data/dtr2/ dtr 1000] [http://eosneo2501.freehostia.com/lettori-mp.htm lettori mp3 creative zen nano plus 256] [http://mwoodley.freehostia.com/html/joss-stone.htm joss stone you had me] [http://darkrone.freehostia.com/small/www-o.htm www o mai it] [http://xmarina.freehostia.com/rulla-com/ rulla com] [http://chibi-evil.freehostia.com/small/private-sex.htm private sex] [http://lizilu.freehostia.com/italsempione-milano/ italsempione milano] [http://soapimpression.freehostia.com/text/foto-di448/ foto di nudo famosi] [http://lizilu.freehostia.com/musica-mp/ musica mp3] [http://adadem.freehostia.com/html/televisori-plasma25/ televisori plasma panasonic 42] [http://irremedy.freehostia.com/view/case-vacanze/ case vacanze grecia mykonos] [http://adadem.freehostia.com/html/maurizio-casagrande/ maurizio casagrande] [http://darkrone.freehostia.com/small/sigma-.htm sigma 18125 mm f3 55 6 dc canon] [http://metalstrangers.freehostia.com/data/bitefight/ bitefight] [http://sailorzanarkand.freehostia.com/directory/comites/ comites] [http://orencat.freehostia.com/library/kandiramassin/ kandiramassin] [http://knopkaaa.freehostia.com/pocket-pc/ pocket pc h6340] [http://joshuas-eyes.freehostia.com/blog/atlas-ufo/ atlas ufo robot film dvd] [http://irremedy.freehostia.com/view/progetto-ovidio/ progetto ovidio] [http://death-stab.freehostia.com/data/hp-nx38/ hp nx 8220 centrino] [http://orencat.freehostia.com/library/dipingere-la/ dipingere la porcellana] [http://a-l-l-o-y.freehostia.com/monterosso-sp/ monterosso sp] [http://cetki.freehostia.com/html/libreria-ecumenica.htm libreria ecumenica in milano] [http://orencat.freehostia.com/library/forca-traduzione/ forca traduzione nelly furtado] [http://semen-serpent.freehostia.com/data/case-vacanza51.htm case vacanza in italia] [http://jmarzluff.freehostia.com/html/incontri-con7.htm incontri con donna campania] [http://irremedy.freehostia.com/view/kit-parabola/ kit parabola decoder satellitare] [http://fiendishupdates.freehostia.com/articles/karakoram.htm karakoram] [http://miss-snoopy25.freehostia.com/new/volo-aereo/ volo aereo ibiza] [http://jmarzluff.freehostia.com/html/i-clandestino.htm i clandestino] [http://nika1984.freehostia.com/resources/nw.htm nw8240 770] [http://cindynmuttnaz.freehostia.com/library/game-cube.htm game cube console] [http://lizilu.freehostia.com/simona-tagli/ simona tagli] [http://resident-raptor.freehostia.com/web/scarica-come.htm scarica come suoneria di antonacci non c] [http://mwoodley.freehostia.com/html/helm-street.htm helm street] [http://aspiringlygodly.freehostia.com/articles/amplificatori-da/ amplificatori da karaoke] [http://sillyrabbittrix.freehostia.com/content/usato-klimo/ usato klimo] [http://metalstrangers.freehostia.com/data/cantar-de/ cantar de nuva] [http://despotic-intern.freehostia.com/blog/copertine-festivalbar1/ copertine festivalbar 2004] [http://mwoodley.freehostia.com/html/kimy.htm kimy] [http://fiendishupdates.freehostia.com/articles/eros-ramazzottti.htm eros ramazzottti] [http://xmarina.freehostia.com/winrar-download/ winrar download] [http://chibi-evil.freehostia.com/small/foto-uomini.htm foto uomini pelosi] [http://nika1984.freehostia.com/resources/auto-noleggio242.htm auto noleggio desenzano garda] [http://soapimpression.freehostia.com/text/quelli-che/ quelli che benpensano] [http://darkrone.freehostia.com/small/match.htm match] [http://big-dreamer24.freehostia.com/lib/cazzo-super.htm cazzo super] [http://soapimpression.freehostia.com/text/wario-ware/ wario ware] [http://irremedy.freehostia.com/view/daniela-trans/ daniela trans] [http://mwoodley.freehostia.com/html/frasi-ironiche.htm frasi ironiche per il compleanno] [http://aspiringlygodly.freehostia.com/articles/licantropi/ licantropi] [http://chibi-evil.freehostia.com/small/luomo-del.htm luomo del confine] [http://miss-snoopy25.freehostia.com/new/nec-nd/ nec nd 3540] [http://cetki.freehostia.com/html/triac.htm triac] [http://semen-serpent.freehostia.com/data/hard-disk788.htm hard disk 2 5 80 esterno] [http://just-ekat.freehostia.com/new/il-piercing/ il piercing sulla figa] [http://miss-snoopy25.freehostia.com/new/allison-teramo/ allison teramo] [http://despotic-intern.freehostia.com/blog/spot-ford/ spot ford] [http://big-dreamer24.freehostia.com/lib/video-ela.htm video ela weber] [http://irremedy.freehostia.com/view/hamlet-router/ hamlet router wireless adsl] [http://ang3l-0f-faith.freehostia.com/lib/hp185/ hp 945] [http://death-stab.freehostia.com/data/je-le/ je le garde pour toi] [http://mevans86.freehostia.com/foto-gratis/ foto gratis free] [http://mevans86.freehostia.com/concessionaria-aprilia/ concessionaria aprilia] [http://eosneo2501.freehostia.com/gianantonio-manzoni.htm gianantonio manzoni] [http://cetki.freehostia.com/html/alpi-carniche.htm alpi carniche] [http://deathsynthe2000.freehostia.com/articles/storie-di.htm storie di fantasmi] [http://a-l-l-o-y.freehostia.com/goldrake-alessio/ goldrake alessio caraturo] [http://mwoodley.freehostia.com/html/foto-martina.htm foto martina colombari] [http://maniak-sk.freehostia.com/data/corale-per/ corale per organo gioia bach] [http://aspiringlygodly.freehostia.com/articles/articolo-di/ articolo di giornale sul malessere giova] [http://maniak-sk.freehostia.com/data/traci-lords/ traci lords] [http://despotic-intern.freehostia.com/blog/crash3/ crash] [http://semen-serpent.freehostia.com/data/poemas-de7.htm poemas de amor gratis] [http://knopkaaa.freehostia.com/www-luana/ www luana it] [http://irremedy.freehostia.com/view/win-mix/ win mix italiano] {{Newarticle}}
+
{{Newarticle}}
  
 
=What causes rust?=
 
=What causes rust?=
Line 85: Line 85:
 
*Slicksand
 
*Slicksand
 
*Featherfill
 
*Featherfill
*[http://www.krylon.com/main/product_template.cfm?levelid=5
+
*[http://www.krylon.com/main/product_template.cfm?levelid=5&sub_levelid=13&productid=1789&content=product_details Krylon rust tough primers]
 +
*[http://www.rustbeeter.com RustBeeter] (made from beets, maybe it's like molasses?)
 +
*Duro Extend
 +
*Devoe Bar-Rust
 +
*Loctite Extend Rust Treatment
 +
*Rustoleum (generally considered a poor choice for automotive applications. Good for cheap shop shelving, etc.
 +
*[http://www.permatex.com/products/automotive/specialized_maintenance_repair/body_interior_trim/auto_Permatex_Rust_Treatment.htm Permatex Rust Treatment]
 +
*[http://ridrust.com/ RidRust]
 +
*[http://solutions.3m.com/wps/portal/3M/en_US/3MAutomotive/Aftermarket/Products/Product-Catalog/?PC_7_0_53BC_root=GST1T4S9TCgv&PC_7_0_53BC_output=html&PC_7_0_53BC_gvel=6DTWTJQPBBgl&PC_7_0_53BC_vroot=GSLPLPKL4Xge&PC_7_0_53BC_node=GSQJ0YVJLSbe&PC_7_0_53BC_theme=en_US_aad_portal&PC_7_0_53BC_command=CustomizePageHandler Rust Fighter]
 +
*DuPont 5717S Metal Conditioner
 +
*http://www.rustx.com/
 +
*[http://www.jasco-help.com/products/prod_mg.htm Jasco]
 +
*Prep-sol
 +
*[http://www.napasco.com/enrustreat.htm Mar-Hyde Rust Converter]
 +
*Rust N-M-E
 +
*http://www.penntoolco.com/catalog/products/products.cfm?categoryID=2182
 +
*[http://www.d-rust-it.com/ rust removal concentrate]
 +
*[http://www.hammerite-automotive.com/ Hammerite]
 +
*[http://www.eurekafluidfilm.com/ Fluid Film]
 +
*Waxoyl
 +
*[http://rustonic.com Rustonic]
 +
*[http://duplicolor.com/products/rustfix.html Duplicolor Rust Fix]
 +
*[http://www.therustdoctor.com/ Rust Doctor]
 +
*[http://bluelightning.zoovy.com/product/RR32 Blue Lightning]
 +
*Picklex-20
 +
*[http://rust007.com/knockout.htm Rust Knockout]
 +
*[http://www.napasco.com/enrustreat.htm Enrust]
 +
*[http://rust007.com/destroyerhome.htm Rust Destroyer]
 +
*Rust-Check
 +
*[http://www.evaporust.com/ Evapo-Rust Rust Remover]
 +
*[http://www.corroless.com/ Corroless]
 +
*[http://www.kleanstrip.com/special.htm Klean Strip Rust Converter]
 +
*[http://www.zerorust.com/ Zero Rust] -- [http://www.zerorust.com/tech.htm tech page], [http://www.zerorust.com/faq.htm faq]. Rust cleaning product is "prep-step", and clearcoat is called "crystal coat"
 +
*Rust Reformer
 +
*[http://www.rustbullet.com Rust Bullet]
 +
*[http://www.ospho.com/ Ospho]
 +
*Oxisolve
 +
*Rust-n-me
 +
*DuPont Metal Conditioner
 +
*PPG Metal Prep
 +
*DuPont Vari-Prime
 +
*All-Metal
 +
 
 +
===Rust removers and "converters"===
 +
After using an acid to remove rust, flush the surface with water and baking soda (confirm or expand on this).
 +
 
 +
When converting/neutralizing rust:
 +
# Get everything off first that you can by sanding and wire brushing (wire brushing will get into the pits better)
 +
# A rust converter/neutralizer containing phospheric acid or another type of acid shold be used
 +
# Be careful of getting this stuff on your concrete floor as it will bubble and decompose it
 +
# Follow the instructions on the bottle when you are done there should be a fine coating on the metal which will help prevent further rust from developing
 +
# This stuff is hard on paintbrushes (eats away the brisles) and you must be very careful of your eyes. Also it will ruin paint so again use caution.
 +
 
 +
Lots of "rust neutralizers/metal etchers/floor etchers/metal conditioners" contain primarily phosphoric acid, which reacts with rust (iron oxide) to create iron phosphate, a hard black substance over which primer can be applied.
 +
 
 +
Don't use battery acid (sulfuric acid) for rust removal. It's too dangerous, and there are many more effective chemicals.
 +
 
 +
*[http://rustbeeter.com/ Rustbeeter] Merchant description: A byproduct of the sugar refining process. Probably similar to molasses. Parts must be submerged. Parts soak in a bucket for usually under a week, but as long as several weeks. Food product. Dry powder that gets mixed with water. Non-acidic or caustic. After use, parts are cleaned with dishsoap and water, dried, and coated.
 +
*[http://www.tinmantech.com/html/must_for_rust_remover_inhibi.php Must for Rust] Merchant description: removes rust and corrosion, non-caustic to skin, needs no neutralizing, primer goes right over it. $28/gallon.
 +
*[http://www.eastwoodco.com/shopping/product/detailmain.jsp?itemID=15974&itemType=PRODUCT&iMainCat=373&iSubCat=374&iProductID=15974 Eastwood Rust Converter] Merchant description: 2-part mix, adheres to bare or rusty steel, and can be topcoated with most coatings. 1 gallon each of the 2-part mix is $125.
 +
*[http://www.rust-cure.com/ Rust Cure] Merchant description: phosphoric acid-based. leaves a thin film that bonds well with most primers and paints. for pricing, need to see this page: http://rustcure.bizland.com/xwheretobuy.html .
 +
*[http://www.eastwoodco.com/jump.jsp?itemID=1124&itemType=PRODUCT Oxisolv Rust Remover] Merchant description: dissolves rust and leaves behind a zinc phosphate coating. Spray/brush/dip. Non-toxic, non-flammable, and re-usable. Must be cleaned off before priming.
 +
*[http://www.eastwoodco.com/jump.jsp?itemID=11122&itemType=PRODUCT Eastwood Rust Dissolver] Merchant description: acid free rust remover, leaves surface ready to paint, plate, or powder coat. Suitable for engine parts, and harmless to copper, brass, aluminum, solder, lead, plastic, rubber, seals, wood or vinyl. Surface must remain wet for product to work. $40/gallon.
 +
*[http://sem.ws/product.php?product_id=164 Rust-Mort] Merchant's description: "Converts rust to a black or grayish, hard, insoluble, protective coating".
 +
*[http://sem.ws/product.php?product_id=206 SEM Rust-Seal] Manufac descrip: "Transforms rust leaving a tough, permanent, black protective coating. RUST-SEAL can be left exposed or may be topcoated with enamels, lacquers or urethanes."
 +
 
 +
(Make sure that none of the above count as "encapsulators". Also, what about the converters that leave a "protective film" on the metal. They say that they don't need neutralization, and they don't need to be washed off. Is this as good as cleaning to bare metal, and then hitting with epoxy primer?)
 +
 
 +
*Vinegar
 +
*Muriatic acid (not for use on body panels, as it causes [http://en.wikipedia.org/wiki/Hydrogen_embrittlement hydrogen embrittlement])
 +
*Toilet cleaner (?)
 +
*Cola (yes, contains phosphoric acid)
 +
*Phosphoric acid: leaves behind a coating of iron phosphate
 +
*Naval jelly (gelled phosphoric acid)
 +
*Mag wheel cleaner (?)
 +
*Molasses (a 1:10 solution of molasses to water can be used for soaking rusty parts, although it loses its strength after several months)
 +
*Powdered household cleaning products such as Comet or Ajax
 +
 
 +
===Rust encapsulators===
 +
Rust encapsulators work by sealing off existing rust, denying it the oxygen it needs to grow.
 +
 
 +
The use of rust encapsulators in hotrodding is controversial. Hotrodders typically divide into 3 distinct camps over the use of rust encapsulation products on vehicles:
 +
 
 +
#Won't use rust encapsulation products at all.
 +
#Will use rust encapsulation products, but not on body panels.
 +
#Will use rust encapsulation products on a variety of parts, including body panels.
 +
 
 +
Arguments against using rust encapsulators:
 +
*Though many rust encapsulation products carry a "lifetime warranty", such guarantees don't involve labor costs, losses, or other related costs.
 +
*For hobbyists, it's often best to stick with a single line of paint/finish products, from bare metal to clearcoat. Using most rust products means that you're outside of the product line for the rest of the finish. So, it may be physically incompatible (resulting in a poor paint job), or it may void the product warranty.
 +
*They're expensive.
 +
*The major paint manufacturers like Sherwin Williams, PPG, and DuPont don't produce a rust encapsulation product. This is thought to be because they couldn't possibly warranty such a product.
 +
*Notably, OEM manufacturers don't use rust encapsulation products.
 +
*Many rust encapsulators require the surface to be lightly rusted first for the product to properly adhere. "Inducing" rust seems wrong to people.
 +
*Rust prevention products are primarily advertised in hobbyist mags, not in periodicals read by professionals in the paint and body industry.
 +
*The thought that the rust still lurks beneath the encapsulator, and hasn't been completely eliminated, is troubling.
 +
*The cultural or conceptual notion that the rust hasn't been removed, just covered by "that black stuff".*
 +
The notion that, after you "encapsulate" rust, it still "lives underneath", is generally correct. There is mobile oxygen in the metal, living beneath the surface, causing more rust.
 +
 
 +
 
 +
Rust encapsulation products are hard to remove from skin. Try soaking in vegetable oil for 30 minutes, or see if there is a specific solvent for the product you're using.
 +
 
 +
When selecting a rust encapsulator, you will need to consider:
 +
 
 +
*Product compatibility?
 +
*What can it be thinned with, and how?
 +
*How long does it take to dry/cure?
 +
*Will it fade in direct sunlight? Is there a UV topcoat available?
 +
*What colors are available?
 +
 
 +
 
 +
*[http://www.eastwoodco.com/shopping/product/detailmain.jsp?itemID=1137&itemType=PRODUCT&iMainCat=373&iSubCat=374&iProductID=1137 Eastwood Rust Encapsulator] Manufacturer description: encapsulates rust and primes in one step. can be used under or over body fillers. compatible with most topcoats. $100/gallon.
 +
*POR-15: "silver" POR-15? Has a filler in it for minor imperfections?
 +
*Zero Rust
 +
 
 +
===Rust preventive oils and waxes===
 +
*[http://www.brownells.com/aspx/NS/store/ProductDetail.aspx?p=1134 Cosmoline] . "Cosmoline" is a trade name for a generic rust preventative which conforms to US military specification MIL-C-11796C. It's a soft, brushable grease that's commonly used for preserving and storing firearms. "Rated to protect polished steel panels from rust for one year in open shed storage, and 30 days, minimum, in a humidity cabinet." $30/gallon
 +
*[http://boeshield.com/index.htm Boeshield T-9] "Designed to penetrate metal pores and dissolve minor corrosion, then leave a resilient waxy coating that lasts for many months." $100/gallon
 +
*[http://www.eastwoodco.com/jump.jsp?itemID=1117&itemType=PRODUCT Eastwood Heavy-Duty Anti-Rust]. Merchant's description: spray-on brown wax film which forms an air and water-tight barrier. won't crack, flake, or peel. used for inside door panels, or to protect bare metal parts during storage. $15/quart
 +
*[http://www.oxisolv.com/html/long_term.html Oxisolv rust inhibitor long term] -- Merchant description: displaces water on metal parts to prevent rust. environmentally safe, bio-degradable, protects steel. Apply by spraying thoroughly, or dipping.
 +
*[http://sem.ws/product.php?product_id=161 SEM internal panel coating] Manufacturer description: "provides corrosion protection to inner body panels and other metal parts"
 +
*[http://solutions.3m.com/wps/portal/3M/en_US/3MAutomotive/Aftermarket/Products/Product-Catalog/?PC_7_0_53BC_root=GST1T4S9TCgv&PC_7_0_53BC_output=html&PC_7_0_53BC_gvel=6DTWTJQPBBgl&PC_7_0_53BC_vroot=GSLPLPKL4Xge&PC_7_0_53BC_node=GS3H3CPLMLbe&PC_7_0_53BC_theme=en_US_aad_portal&PC_7_0_53BC_command=CustomizePageHandler 3M Rust Fighter application wand]
 +
*[http://solutions.3m.com/wps/portal/3M/en_US/3MAutomotive/Aftermarket/Products/Product-Catalog/?PC_7_0_53BC_root=GST1T4S9TCgv&PC_7_0_53BC_output=html&PC_7_0_53BC_gvel=6DTWTJQPBBgl&PC_7_0_53BC_vroot=GSLPLPKL4Xge&PC_7_0_53BC_node=GSQJ0YVJLSbe&PC_7_0_53BC_theme=en_US_aad_portal&PC_7_0_53BC_command=CustomizePageHandler 3M Rust Fighter]
 +
*You can make your own basic rust protection coating from 1 part anhydrous lanolin (available from a pharmacy), and 5 parts paint thinner.
 +
*For machine tools, this is recommended: http://www.clclubricants.com/waylubes.htm .
 +
*Use something that releases rust-inhibiting vapor. Rust-blox vapor tabs, vpi paper, permatex in-charge corrosion inhibitor.
 +
 
 +
===Epoxy primer===
 +
''Main article: [[Epoxy primer]].''
 +
 
 +
Epoxy primer/sealer is a non-porous finish that is typically recommended as the first basecoat over bare steel. Various epoxy primers can also be applied over fiberglass, plastic, or the black iron phosphate coating that remains after "converting" rust.
 +
 
 +
Epoxy primer is a two-part mix, with a hardener that has to be added before spraying. Body fillers and high-build primers can be used on top of epoxy primer.
 +
 
 +
===Seam sealers===
 +
Seam sealers are used to seal roof channels, drip rails, trunk seams, door seams, and other body seams. They can be either one or two-part, and are typically applied over primer, sometimes with the use of a specially-designed caulking gun or spray gun.
 +
 
 +
Lord Corporation makes several seam sealers: [http://www.lord.com/Home/ProductsServices/Adhesives/FusorAutomotiveAftermarketProducts/Products/SealersFoams/tabid/3402/Default.aspx Lord Corporation sealers and foams].
 +
 
 +
3M manufactures several different types of seam sealers: [http://solutions.3m.com/wps/portal/3M/en_US/3MAutomotive/Aftermarket/Products/New-Products/?PC_7_0_5FJC_command=CustomizePageHandler&PC_7_0_5FJC_theme=en_US_aad_portal&PC_7_0_5FJC_output=html&PC_7_0_5FJC_vroot=GSLPLPKL4Xge&PC_7_0_5FJC_gvel=6DTWTJQPBBgl&PC_7_0_5FJC_node=GSWMS8NB1Nbe&PC_7_0_5FJC_root=GST1T4S9TCgv 3M seam sealers].
 +
 
 +
SEM Products makes a [http://sem.ws/product.php?product_id=269 SEM high build self-leveling seam sealer], and a [http://sem.ws/product.php?product_id=98 SEM self-leveling seam sealer].
 +
 
 +
Transtar Autobody Technologies makes a variety of seam sealers: [http://www.tat-co.com/productCategory.asp?ID=6#sub9 Transtar seam sealers].
 +
 
 +
International Epoxies and Sealers: [http://www.internationalepoxies.com/bodysealers.htm International Epoxies and Sealers body sealers].
 +
 
 +
Valvoline makes their [http://www.pliogripbyvalvoline.com/sealers_foam.html Pliogrip line of seam sealers].
 +
 
 +
Evercoat has the [http://www.evercoat.com/productCategory.aspx?cat=41 maxim line of seam sealers].
 +
 
 +
===Metal washes, wax and grease removers===
 +
*[http://www.eastwoodco.com/jump.jsp?itemID=258&itemType=PRODUCT&path=1%2C2%2C458%2C467%2C473&KickerID=39&KICKER Eastwood Metal Wash]. Merchant's description: dry compound that is mixed with water. removes grease and oils from bare metal, and leaves behind corrosion inhibitors that prevent flash rusting and promote paint adhesion. $11 for enough dry mix to make 7 quarts.
 +
*[http://www.aerospace.henkel.com/index.cfm?ID=178 Metalprep 79] manufac: phosphoric acid-based cleaner. leaves surface chemically clean and corrosion free. thoroughly rinse with water when done. brush/spray/dip
 +
*Is DuPont's "Quick-Prep" equivalent to Metalprep?
 +
 
 +
Read this thread thoroughly: http://www.hotrodders.com/forum/what-else-wax-grease-remover-besides-mineral-spirits-51150.html
 +
 
 +
The following are not to be used as metal cleaners: lacquer thinner, acetone, reducers. Use the product within the recommendations of your product system. Cleaners typically vary as to strength, and time they take to evaporate. 
 +
 
 +
Use clean, purpose-designed paint rags for cleaning with cleaners.
 +
 
 +
===Weld-through primer===
 +
Weld-through primer zinc-rich coating that conducts current from a welder, and doesn't burn off when welding. It can provide protection on lap welds and inner weld seams.Weld-through primer is often applied to the mating areas when welding body panels.
 +
 
 +
*3M
 +
*U-Pol
 +
 
 +
===Panel adhesives===
 +
Used to adhere body panels, as an alternative to welding. Need more information on these.
 +
 
 +
==Tools==
 +
*Shop vac
 +
*Putty knife
 +
*Metal brush
 +
*Sand paper. 36 grit to 220 grit.
 +
*Wire wheel on drill. When the wire bristles start to bend one way, reverse the drill and work in the other direction for a while.
 +
*Wire wheel on grinder, or, these discs are considered to be superior to wire wheels: [http://solutions.3m.com/wps/portal/3M/en_US/Manufacturing/Industry/Product-Catalog/Online-Catalog/?PC_7_0_4UVL_root=GST1T4S9TCgv&PC_7_0_4UVL_output=html&PC_7_0_4UVL_gvel=H55CPWS904gl&PC_7_0_4UVL_vroot=81LC4NNTD4ge&PC_7_0_4UVL_node=RCM96XTX07be&PC_7_0_4UVL_theme=en_us_manufacturingindustry_portal&PC_7_0_4UVL_command=CustomizePageHandler 3M clean & strip disc], or [http://solutions.3m.com/wps/portal/3M/en_US/Marine/Home/Products/Catalog/?PC_7_0_4S4T_root=GST1T4S9TCgv&PC_7_0_4S4T_output=html&PC_7_0_4S4T_gvel=RJ5GMFSMV0gl&PC_7_0_4S4T_vroot=GS4JK4Y166ge&PC_7_0_4S4T_node=GSGKXWRKYVbe&PC_7_0_4S4T_theme=en_US_marineproducts_portal&PC_7_0_4S4T_command=AbcPageHandler 3M bristle disc], or [http://solutions.3m.com/wps/portal/3M/en_US/Marine/Home/Products/Catalog/?PC_7_0_4S4T_command=AbcPageHandler&PC_7_0_4S4T_theme=en_US_marineproducts_portal&PC_7_0_4S4T_output=html&PC_7_0_4S4T_vroot=GS4JK4Y166ge&PC_7_0_4S4T_gvel=RJ5GMFSMV0gl&PC_7_0_4S4T_node=GSVDY2CZYDbe&PC_7_0_4S4T_root=GST1T4S9TCgv Surface Conditioning Disc]
 +
*Scotch-brite pads
 +
*Steel toothbrush
 +
*Media blaster
 +
*Blasting cabinet
 +
*Spot blaster
 +
*Welder
 +
*Steel wool
 +
 
 +
Tips
 +
*When using a wire wheel, don't sit in one spot for too long -- it will warp the metal.
 +
 
 +
==Methods==
 +
===Body panel rust removal===
 +
Ideally, only surface rust on body panels is "treated". Anything more than that would mean that the affected area would be cut out, and replaced with fresh metal.
 +
 
 +
====Removing surface rust from body panels====
 +
First, remove all the heavy surface rust with a DA sander and 80-180 grit paper.
 +
To remove surface rust, use naval jelly (jelled phosphoric acid) and steel wool.
 +
#Work in small areas, not larger than a square foot. Wear rubber gloves, and scrub with naval jelly and steel wool.
 +
#Apply jelly with 000 steel wool, rub it in, and allow it to set for a couple of minutes. Don't let it dry. Keep it wet, using a squirt bottle. For inclines, you can also soak some fabric in water, and lay it on the naval jelly.
 +
#Rub again with steel wool. Repeat a few times.
 +
#When finished, wipe off the excess naval jelly with a paper towel, squirt on warm soapy water, and dry thoroughly.
 +
#Wipe down with lacquer thinner.
 +
#Sand with 180 grit.
 +
#Use wax and grease remover, and then spray with epoxy primer.
 +
#From there, you can apply body filler (the epoxy may need to be scuffed, read instructions)
 +
#When the filler work is done, scuff with a red scotch-brite pad.
 +
#Then, apply two more coats of epoxy, followed by high-build primer.
 +
 
 +
====Cutting out rust====
 +
First, make a tape template. Tape off the area that's going to be cut off, leaving a healthy border of good metal. Transfer the tape template to the patch panel, in one piece. Cut out the templated piece from the patch panel. Then, screw the cut-out piece to the car as a temporary guide. From there, rough-shape the patched piece. Cut some slits if necessary, and hammer. Then, make the cut on the body panel, with the patch still screwed to the car. Then, unscrew the panel from the car, and hammer-form it on a bench, anvil, etc. Finally, butt-weld it back onto the car. Weld, with lots of spread-out spot welds (wait for them to cool), so the panel doesn't warp. Then, grind down the welds. Treat with rust protection, then body filler, primer, etc.
 +
 
 +
 
 +
A quarter panel rust fix demonstrating the above is illustrated here: http://www.a2zautoforums.com/showthread.php?t=700
 +
 
 +
 
 +
====Treating light body rust (from storing panels) prior to epoxy====
 +
Sand with 80 grit, wash with wax and grease remover. Use waterborne wax and grease remover, instead of solvent-borne (research exactly what that means), let set 15-30 minutes. Dry with a blower and a tack rag. Spray epoxy.
 +
 
 +
====Getting the entire vehicle body dipped====
 +
Need more info on Redi-Strip. What chemical do they use? What's the cost? Can a hobbyist acquire and use the same chemical that Redi-Strip uses? When the body is returned to you, is it truly completely clean, or does it have to be cleaned to get all of the chemical removed from nooks and crannies, etc.?
 +
 
 +
====Quick fix for exposed areas (dents, etc.)====
 +
If a dent causes an area of bare metal to be exposed. To "hold" it so it won't rust until a paint job is ready to be done: gently bump out the dent, sand, rattle can primer, rattle can sealer.
 +
 
 +
====Do both sides of a panel have to be treated with rust converter/encapsulator?====
 +
Explain this.
 +
 
 +
====Removing pitted rust in body panels====
 +
See: [[pitted rust]].
 +
 
 +
====Fixing rust holes in body panels====
 +
See: [[pitted rust]].
 +
 
 +
====Storing body panels====
 +
Use epoxy primer (AKA epoxy primer/sealer), it won't allow rust. Not the same as regular primer.
 +
Wet-sand down to 400 grit, wash/dry, grind down rust to bare metal, apply body filler where needed, blow off, clean with prep-sol or similar cleaner, tape it up, and prime with epoxy primer.
 +
 
 +
====Removing rust in seams====
 +
A spot blaster is useful.
 +
 
 +
To do it right, you will generally need to pull the seam apart, remove the rust, and then hit it with a rust conversion product. However, sometimes you can open up the layers slightly with a hammer and putty knife used between the spotwelds. Bend the flange open, media blast into the seam, clean, prime with epoxy primer, brush in urethane seam sealer, and close the seam back up. If the seam is not accessible, flood it with a penetrating cavity wax, like 3M's Rustfighter.
 +
 
 +
====Accessing rust between interior panels====
 +
Pressure washer with pencil tip can knock everything loose out.
 +
 
 +
Drill small holes, get a spray wand with a 360-degree head. Then, when done, weld the holes shut.
 +
 
 +
Turn panels around to slosh rust remover around. Blow compressed air inside the panel.
 +
 
 +
Cut hole in panel? Spray rust killer with garden sprayer?
 +
 
 +
A mirror can be used to check areas for rust.
 +
 
 +
Don't spray expanding foam. It absorbs water, and will cause more rust. It can also expand and cause the panels to push out.
 +
 
 +
====How to treat rusty drip-rails?====
 +
#blast
 +
#wash with wax and grease remover
 +
#spray with 2 coats of epoxy
 +
#spray with seam sealer
 +
 
 +
====Plasma spray welding====
 +
With plasma spray welding, metal wire is converted to sprayable form, and used to repair rust holes, fill panel joints, and blend patch panels. One example is the machine sold by [http://www.rustbustersllc.com Rustbusters].
 +
 
 +
====Rusted window channels====
 +
Difficult to fabricate, need more info on this.
 +
 
 +
===Vinyl tops===
 +
Rust is common in vinyl tops. The vinyl gets porous after a few years, and lets in moisture.
 +
 
 +
How to prevent?
 +
 
 +
===Leaf spring rust===
 +
Remove rust, then, ideally, paint them separately. Re-assemble with teflon strips.
 +
 
 +
===Preventing rust at chassis to ground connection===
 +
Silicone dielectric grease, electrical bonding paste; spray well with clear lacquer after bonding the connection.
 +
 
 +
===Cleaning light surface rust off crankshaft===
 +
Have a machine shop do it, or:
 +
 
 +
#Very fine steel wool or scotchbrite pad, and light oil. Rub around the journals in the direction of rotation, not across.
 +
 
 +
OR
 +
 
 +
#Cut 600 grip wet or dry sandpaper into strips the width of the crank journals. Wrap it around the journal, and secure it with tape. Then, make a strap from leather, about one-half the width of the sandpaper strips. Use the strap on the paper in a shoeshine motion. Finish off with some light oil on the sandpaper. Do a few strokes first, then clean the paper, because the rust will clog the sandpaper.
 +
 
 +
LP3 as rust inhibitor on crankshafts?
 +
 
 +
===Electrolysis===
 +
Removing rust with electrolysis -- research this: http://www.stovebolt.com/techtips/rust/electrolytic_derusting.htm , http://hotrodders.com/forum/rust-removal-lower-arms-other-suspension-parts-108384.html , http://www.davidbradley.net/ERR.html , http://antique-engines.com/trailer-electrolysis.htm .
 +
 
 +
advantages: self-limiting (can't remove too much), safe (low electrical current), won't harm good metal, not an acid (less dangerous, and no risk of hydrogen embrittlement)
 +
 
 +
Need: a plastic tub, a stainless steel or iron electrode, water and washing soda (sodium carbonate), and a batter charger. About 1 tablespoon of soda per gallon of water. Can't find washing soda, then lye will work. Wear eye protection and protect skin too. Connect the electrode to the positive battery terminal. Connect the rusted object to the negative terminal. Submerge the object. Make sure the contact is good (may need to clean off some of the rust from the rusty part). Typically takes a few hours, but can take up to overnight. Rinse or scrub with brush to remove final rust debris. May need to re-treat. Oil, wax, or prime soon after. Surface of rusted metals is black after treatment.
 +
 
 +
Be creative to clean oddly-shaped objects:
 +
 
 +
*plastic PVC pipes
 +
*large 2x4 wood boxes lined with plastic sheeting
 +
*suspend an electrode in a cavity
 +
*use a sponge soaked in the electrolyte solution, with a backing electrode, for objects that can't be submerged.
 +
 
 +
The powder used is a mild alkali.
 +
 
 +
===How to remove rust from chrome===
 +
Use mag wheel polish, fine steel wool, crumpled-up pieces of aluminum foil.
 +
 
 +
===Preventing engine rust===
 +
Engine storage spray, or wipe down with [http://www.marvelmysteryoil.com/ Marvel Mystery Oil].
 +
 
 +
Cylinder walls with flash rust: marvel mystery oil, steel wool, etc. Pitted rusting will necessitate a rebuild.
 +
 
 +
===How to de-rust gas tanks===
 +
Put a handful of nuts and bolts in, chain, chainsaw blade, etc., and shake it around a bit to knock out the loose stuff. Not too aggressive -- you'll dent the tank. Then, clean with phosphoric acid. Pour it in, let it sit for up to an hour, then flush with water and baking soda to neutralize. Or, Eastwood has a kit for this: an acid to clean it, and then something to coat it with. However, some people say that the coating can clog up the fuel filter, or trash your OEM sending unit. The best way to do it is to take it out and get it re-tinned.
 +
 
 +
===How to clean engine water jackets or radiator of rust===
 +
Flush with CLR, Kool Klean (can't find). Manufacturers of CLR say that it shouldn't be used in a radiator: http://www.jelmar.com/CLRbasic.asp .
 +
 
 +
When building an engine, to prevent rust: when done washing it and blowing it dry, oil it down, and store it in a plastic bag -- sealed (confirm this).
 +
 
 +
==="Oiling" your car===
 +
In climates that are more prone to rust, cars are sometimes "oiled". Rocker panels, doors, and other body passages are drilled and sprayed inside with oil, used oil, or gelled oil substances. Entire frame and suspension are also oiled. Can be done yearly in very rust-prone climates.
 +
 
 +
Historically, this procedure has been used before driving the car down a dirt road. The dirt sticks to the oil on the underside of the vehicle, providing an effective sealing layer. Consider how, when removing a dirty, oily gasket, the metal beneath it is clean. Same concept.
 +
 
 +
Now, this might be done with an application-specific undercarriage wax or oil.
 +
 
 +
===Preventing MIG wire rust===
 +
Store in a bag with some dessicant packets. Here's a list of dessicants: [http://en.wikipedia.org/wiki/List_of_desiccants List of dessicants]. Also, can use small old refrigerator with 100 watt bulb inside, for storing rods and wires. Stays about 100 degrees. Small fan inside too.
 +
 
 +
===Underside rust removal===
 +
Best not to do this as overhead work. Tilt the car on a rotisserie, or raise it significantly overhead.
 +
 
 +
Another option is to keep the car low to the ground, and, with plastic sheeting and duct tape, seal the area between car and floor. Leave the rear area of the plastic "tent" open for access. At the front of the "tent", affix a shop vac hose (exhaust). Blast.
 +
 
 +
===Rustproofing brake rotors===
 +
Zinc dip, also Eastwood has some solutions? Research this.
 +
 
 +
===Axle tube rust===
 +
When rebuilding a rear end, the rust can be cleaned out with naval jelly/shoving rags down it with a broomstick.
 +
 
 +
===Cleaning hand tools===
 +
Tumble in a cement mixer with oil and sand. Or, soak in a bucket with parts cleaner or paint thinner.
 +
 
 +
===Rust prevention on tools===
 +
Keep tools in a wooden toolbox. Also, use a shop dehumidifier. Avoid dust on your tools, as it can attract moisture, and thus, rust.
 +
 
 +
===Electronic rust inhibition===
 +
*[http://www.counteractrust.com/ CounterAct Electronic Rust Protection]?
 +
*[http://www.ruststopnorthamerica.com/electronic-rustproofing-rust-proofing.htm Rust Stop North America]
 +
 
 +
This is known as [http://en.wikipedia.org/wiki/Cathodic_protection cathodic protection]? Research this. And: [http://en.wikipedia.org/wiki/Sacrificial_anode sacrificial anode] and [http://en.wikipedia.org/wiki/Galvanic_anode galvanic anode].
 +
 
 +
===Frame rust===
 +
Sandblasting or dipping is best. Then, stripping wheel or wire wheel is next-best. Can be professionally sandblasted and powder-coated for ~$250 at a good price.
 +
 
 +
Patching is usually not worthwhile, unless it's a special or valuable frame. Too easy to replace, and too much potential structural damage. Has to be done perfectly. Can be replaced with steel of the same gauge as the original frame, and welded in to place.
 +
 
 +
Where is the rust on the frame? In a critical stress area? How bad is it?
 +
 
 +
For minor surface rusting, with mostly metal showing through, it's OK to just powder-coat it.
 +
 
 +
OR:
 +
 
 +
#blast/wire wheel
 +
#phosphoric acid
 +
#clean off acid with thinner
 +
#etching primer
 +
#epoxy primer
 +
 
 +
====Cleaning the inside of a boxed, open-ended frame====
 +
Blow out all the dirt, etc. Then, attach a strong towel to some strong cord. Soak the towel with rust treatment chemical, and pull it through the frame.
 +
 
 +
===Media blasting rust===
 +
*Sand is not recommended for media blasting panels. It acts like little hammers, warping panels with compressive forces (analagous to hail). Technically, it can be done, but extreme caution must be used.
 +
*Use softer media (list examples):
 +
**55 grit silica-based media
 +
**[http://en.wikipedia.org/wiki/Sugar_sand Sugar sand] is finer and less-damaging than regular sand.
 +
*Can sandblasting "increase" rust? Or, if the rust is removed and the metal is sealed, shouldn't it be eliminated? Some thoughts on this are:
 +
**Although sandblasting may appear to have removed all the rust to the naked eye, it hasn't really done so.
 +
**It's caused by water in the air compressor line, as sand will harbor some moisture. Also, compressed air contains moisture. And, sand has salt in it. A moisture trap in the line should solve the problem with the water in the air line.
 +
**Sand by hand after sandblasting, to eliminate this issue.
 +
*Many panels have seams, hems, and bends that are inaccessible by blasting, and can hold moisture and rust. A spot blaster is recommended.
 +
*One option is to use chemical paint stripper, then use a sandblaster to lightly "dust" the remaining rust.
 +
*Media blasting can remove good metal from body panels too. Also, used media can have metal particles left in the media.
 +
*Soda blasting can remove light rust, and won't warp panels. However, when soda blasting body panels, the resultant film can negatively affect finish adhesion. Epoxy primer can peel off. Soda blast medium must be "neutralized". 24 or 36 grit grinder, followed by warm water with soap. Do this with a scuff pad, and rinse thoroughly. Some finish companies specifically advise against the use of their products on soda-blasted finishes, which makes its use contentious.
 +
 
 +
 
 +
 
 +
=Miscellaneous=
 +
 
 +
==Flooded vehicles==
 +
Flooded vehicles can be very difficult to handle, as there can be rust in any and all places. They are best avoided, unless it's the car that you really want.
 +
 
 +
==What's galvanization?==
 +
"Galvanizing" typically refers to hot-dip galvanizing, a process by which iron or steel is coated with a thin layer of zinc, by dipping it in a molten bath of zinc. Galvanized steel can be welded. It's been used for more than 150 years.
 +
 
 +
Zinc oxidizes when exposed to air, forming zinc oxide, which then reacts with water molecules in the air to form zinc hydroxide, which then reacts with carbon dioxide in the air to form zinc carbonate. Zinc carbonate (the final "galvanizing" layer), is a thin but very tough protective layer. It also acts as a "sacrificial anode". It will corrode before the steel it is protecting.
 +
 
 +
Many modern automotive body panels are galvanized.
 +
 
 +
You can buy cold galvanizing spray (list examples here)
 +
 
 +
==Hydrogen embrittlement==
 +
All acids contribute hydrogen to metal. This causes hydrogen embrittlement, which weakens the metal. Unconfirmed: you can "bake" the hydrogen out at 400 degrees F, after exposing a metal to acid.
 +
 
 +
==Fiberglass resin patches==
 +
One technique that has been recommended is to grind/clean the rust, tape the underside of the panel to be patched, and then fill the holes with fiberglass resin, then paint and undercoat. This trick is not really a good idea -- when the body flexes, there will be cracks in the fiberglass pieces. Metal also expands at different rates than fiberglass, causing cracks to form, allowing more rust to form in these cracks.
 +
 
 +
==Do metal etches leave coating?==
 +
Follow up on metal etches like DuPont's Metal Etch or POR's Metal Ready leaving a phosphoric acid coating on the metal that will prevent flash rusting while storing.
 +
 
 +
==How to remove rust protection==
 +
How to remove old rust protection finishes? Or undercoating?
 +
 
 +
*Wire wheel
 +
*Brake cleaner
 +
*Kerosene
 +
*Heat gun
 +
*EZ-Off oven cleaner
 +
*Mineral spirits
 +
*Freeze with dry ice, then chisel out
 +
*Wallpaper steamer
 +
 
 +
==What about riveting in patch panels?==
 +
Very low-end solution, like fiberglass patching metal. Panel adhesives are a better choice when you can't weld.
 +
 
 +
 
 +
 
 +
=Resource dump=
 +
'''Drop links in here if they're relevant to this article. They'll be reviewed, incorporated, and referenced.'''
 +
 
 +
*[http://www.theruststore.com/rust_info.aspx articles at theruststore.com]
 +
*http://www.corrosionsource.com/index.htm
 +
*[http://www.fertanamerica.com/ Fertan rust remover]
 +
*[http://en.wikipedia.org/wiki/Galvanization Galvanization]
 +
*[http://www.safestrustremover.com/ SafestRustRemover.com]
 +
*[http://www.instructables.com/id/E17UQMY28PEQ6T2A5Z/?ALLSTEPS Electrolytic rust removal]
 +
*[http://www.hotrodders.com/forum/good-durable-paint-frame-98391-2.html rust protection paint]
 +
*http://counteractrust.com/
 +
*http://en.wikipedia.org/wiki/Pickling_%28metal%29
 +
*http://en.wikipedia.org/wiki/Pickle_liquor
 +
*[http://www.finishing.com/116/94.shtml e-coating]
 +
*http://www.novelindia.com/Stainless_Steel_Pickling_Passivation_Chemical.htm
 +
*[http://www.metalwebnews.com/howto/rust/rust.html rust primer]
 +
*[http://www.theruststore.com/rust_info.aspx rust removal and prevention articles]
 +
*[http://www.tinmantech.com/html/faqs.php#rust rust faqs and info]
 +
*[http://antique-engines.com/electrol.asp rust removal by electrolysis]
 +
*[http://www.rowand.net/Shop/Tools/Electrolysis.htm rust removal]
 +
*[http://www.stovebolt.com/techtips/rust/electrolytic_derusting.htm electrolytic rust removal]
 +
*[http://www.brownells.com/aspx/NS/store/ProductDetail.aspx?p=1134 Cosmoline]
 +
*http://www.jasco-help.com/products/prod_mg.htm
 +
*[http://www.restorick.com/tech/topic.asp?TOPIC_ID=37 zero rust application tips]
 +
 
 +
=Related resources=
 +
*[http://www.sizes.com/tools/sandpaper.htm Sandpaper sizes]
 +
*[http://solutions.3m.com/wps/portal/3M/en_US/Manufacturing/Industry/Product-Catalog/Abrasives/ 3M industrial abrasives]
 +
*[http://assist.daps.dla.mil/quicksearch/basic_profile.cfm?ident_number=9324 US military specification covering Cosmoline]
 +
*[http://en.wikipedia.org/wiki/Rust Rust]
 +
*[http://en.wikipedia.org/wiki/Corrosion Corrosion]
 +
 
 +
=References=
 +
*[http://www.metalwebnews.com/howto/rust/rust.html MetalWeb Rust Primer]
 +
*[http://www.bhi.co.uk/hints/rust.htm Electrolytic Rust removal FAQ]
 +
*[http://en.wikipedia.org/wiki/Galvanization Galvanization, from wikiP]
 +
*[http://en.wikipedia.org/wiki/Hematite, from wikiP]
 +
*[http://en.wikipedia.org/wiki/Magnetite, from wikiP]
 +
*[http://en.wikipedia.org/wiki/Conversion_coating, from wikiP]
 +
*[http://en.wikipedia.org/wiki/Iron_oxide, from wikiP]
 +
*[http://science.howstuffworks.com/question445.htm How does rust work?] HowStuffWorks.com
 +
*[http://www.a2zautoforums.com/showthread.php?t=700 Quarter panel rust fix], ''A2Z Automotive Forums'', March 26, 2002.
 +
*[http://www.hotrodders.com/forum/rust-what-acceptable-permanent-ways-get-rid-47303.html Acceptable ways to handle rust], ''Hotrodders Bulletin Board'', September 7, 2004.
 +
*[http://hotrodders.com/forum/rust-pits-39.html Rust pits], ''Hotrodders Bulletin Board'', November 27, 2001.
 +
*[http://hotrodders.com/forum/rustbusters-good-bad-40.html Rustbusters: good or bad?], ''Hotrodders Bulletin Board'', December 4, 2001.
 +
*[http://hotrodders.com/forum/rust-70.html Rust], ''Hotrodders Bulletin Board'', January 26, 2002.
 +
*[http://hotrodders.com/forum/rust-210.html Rust], ''Hotrodders Bulletin Board'',  June 15, 2002.
 +
*[http://hotrodders.com/forum/pitted-rust-280.html Pitted Rust], ''Hotrodders Bulletin Board'', July 26, 2002.
 +
*[http://hotrodders.com/forum/removing-interior-rust-1664.html Removing that interior rust], ''Hotrodders Bulletin Board'', September 29, 2002.
 +
*[http://www.eastwoodco.com/jump.jsp?itemID=1476&itemType=CATEGORY&iMainCat=688&iSubCat=1476 Treating rusted body panels] ''Eastwood Company''.
 +
*[http://hotrodders.com/forum/how-do-i-address-rust-404.html How do I address rust?], ''Hotrodders Bulletin Board'', October 7, 2002.
 +
*[http://hotrodders.com/forum/rust-spot-406.html Rust spot], ''Hotrodders Bulletin Board'', October 7, 2002.
 +
*[http://hotrodders.com/forum/what-would-good-rust-proof-inside-new-panels-64093.html What would be good to rust proof the inside of new panels?], ''Hotrodders Bulletin Board'', June 11, 2005.
 +
*[http://hotrodders.com/forum/completely-covered-surface-rust-help-458.html Completely covered with surface rust...help], ''Hotrodders Bulletin Board'', October 24, 2002.
 +
*[http://hotrodders.com/forum/d-sanders-rust-461.html D/A sanders and rust], ''Hotrodders Bulletin Board'', October 25, 2002.
 +
*[http://hotrodders.com/forum/chrome-wheels-rust-634.html Chrome wheels rust], ''Hotrodders Bulletin Board'', December 9, 2002.
 +
*[http://hotrodders.com/forum/filling-up-holes-body-including-rust-holes-648.html Filling up holes in body, including rust holes], ''Hotrodders Bulletin Board'', December 12, 2002.
 +
*[http://hotrodders.com/forum/surface-rust-791.html Surface rust], ''Hotrodders Bulletin Board'', January 12, 2003.
 +
*[http://hotrodders.com/forum/rust-dimples-843.html Rust dimples], ''Hotrodders Bulletin Board'', January 20, 2003.
 +
*[http://hotrodders.com/forum/some-rust-floor-pans-suggestions-877.html Some rust in the floor pans. Suggestions?], ''Hotrodders Bulletin Board'', January 26, 2003.
 +
*[http://hotrodders.com/forum/what-rust-treatment-will-resist-welding-frame-892.html What rust treatment will resist welding -- frame?], ''Hotrodders Bulletin Board'', January 29, 2003.
 +
*[http://hotrodders.com/forum/rust-treatment-982.html Rust treatment], ''Hotrodders Bulletin Board'', February 18, 2003.
 +
*[http://hotrodders.com/forum/rust-1054.html Rust], ''Hotrodders Bulletin Board'', March 4, 2003.
 +
*[http://hotrodders.com/forum/surface-rust-removal-1135.html Surface rust removal.], ''Hotrodders Bulletin Board'', March 20, 2003.
 +
*[http://hotrodders.com/forum/rust-pitting-1170.html Rust pitting!], ''Hotrodders Bulletin Board'', March 26, 2003.
 +
*[http://hotrodders.com/forum/first-hints-rust-1197.html First hints of rust], ''Hotrodders Bulletin Board'', April 1, 2003.
 +
*[http://hotrodders.com/forum/getting-interior-rust-1719.html Getting at interior rust], ''Hotrodders Bulletin Board'', November 15, 2002.
 +
*[http://hotrodders.com/forum/rusty-gas-tank-help-6055.html Rusting gas tank help], ''Hotrodders Bulletin Board'', January 25, 2003.
 +
*[http://hotrodders.com/forum/rust-my-cylinders-7045.html Rust in my cylinders], ''Hotrodders Bulletin Board'', March 10, 2003.
 +
*[http://hotrodders.com/forum/rust-sludge-rear-10753.html Rust and sludge in the rear], ''Hotrodders Bulletin Board'', May 18, 2003.
 +
*[http://hotrodders.com/forum/rust-proofing-parts-14365.html Rust proofing parts], ''Hotrodders Bulletin Board'', October 25, 2002.
 +
*[http://hotrodders.com/forum/snow-salt-causes-rust-15563.html Is it the snow or the salt that causes rust?], ''Hotrodders Bulletin Board'', February 21, 2003.
 +
*[http://hotrodders.com/forum/evapo-rust-18521.html Evapo-Rust], ''Hotrodders Bulletin Board'', June 25, 2003.
 +
*[http://hotrodders.com/forum/small-rust-patch-anything-else-i-can-do-19405.html Small rust patch -- anything else I can do?], ''Hotrodders Bulletin Board'', July 12, 2003.
 +
*[http://hotrodders.com/forum/primer-wont-rust-27650.html Primer that won't rust...], ''Hotrodders Bulletin Board'', November 10, 2003.
 +
*[http://hotrodders.com/forum/rust-pits-19686.html Rust pits], ''Hotrodders Bulletin Board'', July 17, 2003.
 +
*[http://hotrodders.com/forum/phosphoric-acid-prevention-flash-surface-rust-19885.html Phosphoric acid + prevention of flash/surface rust], ''Hotrodders Bulletin Board'', July 20, 2003.
 +
*[http://hotrodders.com/forum/week-later-rusting-through-zero-rust-20052.html Weeks later - rusting through the Zero Rust], ''Hotrodders Bulletin Board'', July 23, 2003.
 +
*[http://hotrodders.com/forum/how-protect-rust-until-i-paint-21663.html How to protect from rust until I paint], ''Hotrodders Bulletin Board'', August 21, 2003.
 +
*[http://hotrodders.com/forum/rustolem-24592.html Rustoleum], ''Hotrodders Bulletin Board'', September 29, 2003.
 +
*[http://hotrodders.com/forum/body-work-rust-24876.html Body work (rust)], ''Hotrodders Bulletin Board'', October 2, 2003.
 +
*[http://hotrodders.com/forum/best-blast-media-rust-removal-26861.html Best blast media for rust removal], ''Hotrodders Bulletin Board'', October 29, 2003.
 +
*[http://hotrodders.com/forum/zero-rust-28325.html Zero Rust], ''Hotrodders Bulletin Board'', November 20, 2003.
 +
*[http://hotrodders.com/forum/frame-rust-prevention-35589.html Frame rust prevention], ''Hotrodders Bulletin Board'', March 8, 2004.
 +
*[http://hotrodders.com/forum/removing-sunbaked-suface-rust-before-priming-35757.html Remove sunbaked surface rust before priming], ''Hotrodders Bulletin Board'', March 10, 2004.
 +
*[http://hotrodders.com/forum/rusted-39-ford-frame-36408.html Rusted '39 Ford frame], ''Hotrodders Bulletin Board'', March 21, 2004.
 +
*[http://hotrodders.com/forum/welding-rust-spots-floor-38798.html Welding rust spots in floor], ''Hotrodders Bulletin Board'', May 3, 2004.
 +
*[http://hotrodders.com/forum/galvanizing-frame-567.html Galvanizing a frame], ''Hotrodders Bulletin Board'', November 19, 2002.
 +
*[http://hotrodders.com/forum/gas-tank-rust-45806.html Gas tank rust], ''Hotrodders Bulletin Board'', August 17, 2004.
 +
*[http://hotrodders.com/forum/best-rust-inhibitor-40799.html Best rust inhibitor], ''Hotrodders Bulletin Board'', June 4, 2004.
 +
*[http://en.wikipedia.org/wiki/Naval_Jelly Naval Jelly], ''Wikipedia'', retrieved April 24, 2007.
 +
*[http://hotrodders.com/forum/rust-coat-primer-52865.html Rust-coat primer], ''Hotrodders Bulletin Board'', November 27, 2004.
 +
*[http://hotrodders.com/forum/chassis-rust-repair-54190.html Chassis rust repair], ''Hotrodders Bulletin Board'', December 15, 2004.
 +
*[http://hotrodders.com/forum/internal-rust-randy-ferguson-57263.html Internal rust], ''Hotrodders Bulletin Board'', February 1, 2005.
 +
*[http://hotrodders.com/forum/getting-rust-out-nooks-crannies-60460.html Getting rust out of nooks and crannies], ''Hotrodders Bulletin Board'', March 27, 2005.
 +
*[http://en.wikipedia.org/wiki/Hydrogen_embrittlement Hydrogen embrittlement], ''Wikipedia'', retrieved April 24, 2007.
 +
*[http://hotrodders.com/forum/new-motor-rust-cylinder-walls-59015.html New motor, rust on cylinder walls], ''Hotrodders Bulletin Board'', March 2, 2005.
 +
*[http://hotrodders.com/forum/secrets-surface-rust-removal-revealed-55679.html Secrets of surface rust removal revealed], ''Hotrodders Bulletin Board'', January 8, 2005.
 +
*[http://en.wikipedia.org/wiki/Hydrochloric_acid Hydrochloric acid], ''Wikipedia'', retrieved April 24, 2007.
 +
*[http://hotrodders.com/forum/newbie-question-rust-problems-61680.html Newbie question, and rust problems], ''Hotrodders Bulletin Board'', April 21, 2005.
 +
*[http://hotrodders.com/forum/removing-rust-inside-frames-64002.html Removing rust on the inside of frames], ''Hotrodders Bulletin Board'', June 9, 2005.
 +
*[http://hotrodders.com/forum/rust-creeping-seam-what-do-do-64202.html Rust creeping from seam, what to do?], ''Hotrodders Bulletin Board'', June 13, 2005.
 +
*[http://hotrodders.com/forum/rust-removal-trick-maybe-64839.html Rust removal trick], ''Hotrodders Bulletin Board'', June 26, 2005.
 +
*[http://hotrodders.com/forum/gettin-old-rusty-spring-back-prime-shape-65335.html Getting an old rusty spring back to prime shape], ''Hotrodders Bulletin Board'', July 6, 2005.
 +
*[http://hotrodders.com/forum/rust-around-vinyl-top-66610.html Rust around the vinyl top], ''Hotrodders Bulletin Board'', July 24, 2005.
 +
*[http://hotrodders.com/forum/cure-rusty-tank-67703.html A cure for rusty tank], ''Hotrodders Bulletin Board'', August 8, 2005.
 +
*[http://hotrodders.com/forum/cleaning-old-rusty-tools-68221.html Cleaning old rusty tools], ''Hotrodders Bulletin Board'', August 15, 2005.
 +
*[http://hotrodders.com/forum/rust-proofing-oil-72414.html Rust proofing with oil], ''Hotrodders Bulletin Board'', October 19, 2005.
 +
*[http://hotrodders.com/forum/new-have-question-about-panel-rust-repair-76001.html Question about panel rust repair], ''Hotrodders Bulletin Board'', December 12, 2005.
 +
*[http://www.hotrodders.com/forum/hmmm-rust-removal-answer-please-77479-2.html Rust in flooded cars], ''Hotrodders Bulletin Board'', December 30, 2005.
 +
*[http://hotrodders.com/forum/best-way-clean-rust-chrome-78043.html Best way to clean rust from chrome], ''Hotrodders Bulletin Board'', January 6, 2006.
 +
*[http://hotrodders.com/forum/wirewheeling-rust-79024.html Wirewheeling rust], ''Hotrodders Bulletin Board'', January 16, 2006.
 +
*[http://hotrodders.com/forum/rust-pitting-82402.html Rust pitting], ''Hotrodders Bulletin Board'', February 22, 2006.
 +
*[http://hotrodders.com/forum/magic-rust-removers-82287.html Magic rust removers?]' ''Hotrodders Bulletin Board'', February 21, 2006.
 +
*[http://hotrodders.com/forum/what-spray-sandblasted-steel-kill-rust-79237.html What to spray on sandblasted steel to kill rust?] ''Hotrodders Bulletin Board'', January 19, 2006.
 +
*[http://hotrodders.com/forum/fixing-rust-between-seams-85445.html Fixing rust between seams], ''Hotrodders Bulletin Board'', March 27, 2006.
 +
*[http://hotrodders.com/forum/removing-some-kind-rust-protection-86799.html Removing rust protection], ''Hotrodders Bulletin Board'', April 13, 2006.
 +
*[http://hotrodders.com/forum/how-remove-rust-under-car-floor-87359.html How to remove rust from under car floor], ''Hotrodders Bulletin Board'', April 19, 2006.
 +
*[http://spi.forumup.org/about156-spi.html Soda blasting], ''SPI Users Forum'', February 25, 2006.
 +
*[http://hotrodders.com/forum/surface-rust-inside-door-89225.html Surface rust on inside of door], ''Hotrodders Bulletin Board'', May 12, 2006.
 +
*[http://hotrodders.com/forum/rust-pits-89610.html Rust pits], ''Hotrodders Bulletin Board'', May 17, 2006.
 +
*[http://hotrodders.com/forum/how-treat-light-body-rust-prior-epoxy-89957.html How to treat light body rust prior to epoxy], ''Hotrodders Bulletin Board'', May 21, 2006.
 +
*[http://hotrodders.com/forum/preventing-rust-ground-chasis-connections-90035.html Preventing rust at ground to chassis connections], ''Hotrodders Bulletin Board'', May 22, 2006.
 +
*[http://hotrodders.com/forum/rusteeeed-inside-outside-98470.html Rusted from the inside or outside], ''Hotrodders Bulletin Board'', September 18, 2006.
 +
*[http://hotrodders.com/forum/mig-wire-rust-103305.html MIG wire rust], ''Hotrodders Bulletin Board'', November 26, 2006.
 +
*[http://hotrodders.com/forum/cleaning-rust-off-crankshaft-106495.html Cleaning rust off crankshaft], ''Hotrodders Bulletin Board'', January 11, 2007.
 +
*[http://hotrodders.com/forum/surface-rust-prep-before-paint-question-again-94158.html Surface rust prep before paint], ''Hotrodders Bulletin Board'', July 20, 2006.
 +
*[http://hotrodders.com/forum/quick-question-about-rustoleum-97198.html Quick question about Rustoleum], ''Hotrodders Bulletin Board'', September 2, 2006.
 +
*[http://hotrodders.com/forum/solution-preventing-all-rust-96594.html Solution to preventing all rust?], ''Hotrodders Bulletin Board'', August 26, 2006.
 +
*[http://hotrodders.com/forum/save-your-rusty-floor-board-108056.html Save your rusty floor board], ''Hotrodders Bulletin Board'', February 1, 2007.
 +
*[http://hotrodders.com/forum/hard-reach-rust-104414.html Hard to reach rust], ''Hotrodders Bulletin Board'', December 13, 2006.
 +
*[http://hotrodders.com/forum/stopping-rust-inside-103320.html Stopping rust from the inside], ''Hotrodders Bulletin Board'', November 26, 2006.
 +
*[http://hotrodders.com/forum/rust-treatment-repair-109939.html Rust treatment and repair], ''Hotrodders Bulletin Board'', February 25, 2007.

Revision as of 22:15, 29 September 2007

Personal tools
Namespaces
Variants
Actions
Navigation
Categories
Toolbox