TH400 rebuild tech

From Crankshaft Coalition Wiki
Jump to: navigation, search
(Transfer case info)
 
Line 1: Line 1:
{{youcanedit}}
 
 
==Rebuilding the T-400==
 
 
===Clearance in clutch packs:===
 
 
*Direct and forward clutch drums:
 
 
0.050" to 0.080" in each drum works well with 5 frictions.
 
 
Typically the thicker steel plates are used in the direct clutch drum. These can be mixed with thinner steels used in forward drum when setting clearance.
 
Try to maintain thicker steels in the direct clutch drum.  Thicker steels take the heat of shifting better.
 
 
*Intermediate clutch pack:
 
 
0.040" to 0.060" clearance in the intermediate clutch with 3 frictions.
 
Always use a thicker snap ring 0.095" - 0.100" to retain the pressure plate.
 
 
===Full manual shift modifications===
 
 
FULL manual shifts means just that. You must move the shifter for every shift up or down. NO Automatic shifts.
 
 
There are two steel governor fluid tubes out the rear of the main valve body. Remove these tubes. Plug the holes in valve body. 3/8-16 tap and set screws work. Use liquid thread locking chemical.
 
 
[[image:Gov_tube_holes.jpg]]
 
 
 
A new 0.110" (#35 or 7/64" bit) hole needs to be drilled in the proper place to loop the governor fluid. Check photos here for location.
 
 
[[file:T-400_full_manual_loop03.jpg]]
 
 
 
You must also modify the 1-2 shift valve as listed below for FULL manual shift conversion:
 
 
The T-400 has a over-ride shift that will shift out of low gear even if you have manually selected low. It was designed to prevent engine damage.
 
You can eliminate this feature by performing the following modifications to the valve body.
 
 
You must remove the 1-2 shift valve and grind two flats on the land designated by the arrow.
 
You must plug the exhaust hole in the valve body also designated.
 
 
[[file:1-2_shift_valve.jpg]]
 
 
Simply grind two flats on the shift valve and deburr them.
 
You can plug the hole with a brass dowel or a check ball. To use a check ball you will have to first drill the hole larger and then drive the check ball in place.
 
 
 
Drill the marked holes to .125" (1/8") for street use.  At the 1-2 shift hole location (designated #2), drill the small hole out.
 
 
For a heavy duty application: 3rd gear shift use a .150" drill (#25 bit, .149) and leave the 1-2 check ball out. '''Caution:''' A 34 element sprag needs to used with the 1-2 check ball removed. 
 
 
Near the bottom of the separator plate in photo, the hole in the round black circle (designated 'Dual Feed') should be plugged when the dual feed modifications are performed with the center lip seal removed from the direct clutch drum.
 
 
[[file:T-400_feed_holes03.jpg]]
 
 
 
Another mod is blocking the 2-3 accumulator. I do this with a set screw. You tap the hole and install the set screw available from any hardware store. You will remove the 2-3 accumulator piston, discard the spring.  This firms up the 2-3 shift. 
 
 
Re-Install the piston in the hole.  Do not use a plastic piston, they break.
 
 
Tap the hole that feed the backside, or spring side, of the accumulator piston. Install the set screw. Re-install the accumulator piston.
 
 
What this does is eliminates accumulator function on the 2-3 shift. This results in a very positive 2-3 shift. You could leave 2-3 accumulator function in place and go slightly bigger on the feed hole.
 
 
[[file:100_2218-1.jpg]]
 
 
 
===Boost valve modification===
 
 
(Full manual shift only)
 
 
Modification of the boost valve to have static line pressure and vacuum modulator replaced with aluminum plug. This modification of the boost valve avoids the run away high line pressure in reverse.
 
 
Grind a flat spot on the large spool valve land with arrow pointed at it. It is not fussy, 1/4" to 3/8" wide is fine.
 
 
[[file:400boost01.jpg]]
 
 
 
Hole location in case to plug. This is shown with the pump removed from the case. This passage must be plugged if boost valve land is ground with flat spot.
 
 
[[file:400boost02.jpg]]
 
 
 
Method #2 to plug passage in case: You can remove the valve body and plug the hole shown in photo if pump removal is not going to happen. Perform this method or the method posted above. Both are not needed.
 
 
You can slip a 1/4" check ball into the square hole and push it into the round passage at the base of this square hole.
 
 
[[file:Block_rev_hole.jpg]]
 
 
 
After the boost valve modification, you can install an aluminum plug that blocks the modulator valve in place. The original bolt and bracket from the vacuum modulator holds the aluminum plug in place.
 
 
[[file:T-400_modulator_plug.jpg‎ ]]
 
 
==Valve body mods, automatic shifts==
 
 
The T-400 has a over-ride shift that will shift out of low gear even if you have manually selected low. It was designed to prevent engine damage.
 
You can eliminate this feature by performing the following modifications to the valve body.
 
 
You must remove the 1-2 shift valve and grind two flats on the land designated by the arrow.
 
You must plug the exhaust hole in the valve body also designated.
 
 
[[file:1-2_shift_valve.jpg]]
 
 
Simply grind two flats on the shift valve and deburr them.
 
You can plug the hole with a brass dowel or a check ball. To use a check ball you will have to first drill the hole larger and then drive the check ball in place.
 
 
 
Drill the marked holes at 0.125" (1/8") for street use. At the 1-2 shift hole location (circled #2), drill out the small hole.
 
 
For a heavy duty application: 3rd gear shift use 0.150" (#25 bit, 0.1495") drill and leave the 1-2 check ball out. Caution: A 34 element sprag needs to used with the 1-2 check ball removed.
 
 
Near the bottom of the separator plate in photo, the hole in the round black circle (designated 'Dual Feed') should be plugged when the dual feed modifications are performed with the center lip seal removed from the direct clutch drum.
 
 
[[file:T-400_feed_holes03.jpg]]
 
 
 
Another mod is blocking the 2-3 accumulator. I do this with a set screw. You tap the hole and install the set screw available from any hardware store. This firms up the 2-3 shift.
 
 
Re-install the piston in the bore.  DO NOT use a plastic piston, they break.
 
 
[[file:100_2218-1.jpg]]
 
 
 
Next pull out the valve shown below. IF the spring is on the outer end as shown, remove the spring. This will firm up 1-2 light throttle shifts. For a firmer 1-2 shift, install a small spring on the inside of this valve. The OEM outer spring is too large to fit into the bore first.
 
 
[[file:t-400 acc valve.jpg]]
 
 
 
 
==T-400 transmission rebuild tech==
 
==T-400 transmission rebuild tech==
 
'''NOTE:'''
 
'''NOTE:'''
*This information and photos are meant to help those who wish to rebuild their own transmission, however this is not intended to be a replacement for an ATSG or factory tech manual. First time builders will likely need a tech manual. Recommended is an ATSG rebuild manual, HP Books "How to Rebuild and Modify the T-400", and this post for those new to transmissions.  
+
*This information and photos are meant to help those who wish to rebuild their own transmission, however this is not intended to be a replacement for an ATSG or factory tech manual. First time builders will likely need a tech manual. Recommended is an ATSG rebuild manual, and [http://www.amazon.com/Rebuild-Modify-Transmissions-Design-Workbench/dp/1934709204/ref=pd_bxgy_b_img_y How to Rebuild & Modify GM Turbo 400 Transmissions (S-A Design Workbench Series)], and this post for those new to transmissions.  
  
The article by jakeshoe can be seen in the Hotrodders forum thread [http://www.hotrodders.com/forum/t-400-build-tips-photos-145318.html T-400 Build Tips With Photos]. Also covered are some modifications that are not usually required, but are still good to do.
+
 
 +
Besides the basic rebuild, also shown here are some modifications that are not usually required, but are still good to do.
  
 
===Shift shaft seal replace===
 
===Shift shaft seal replace===
After you have disassembled your trans and cleaned the mostly bare case, I recommend you change the shift shaft seal, kick down connector o-ring, and rear case bushing.
+
After you have disassembled your trans and cleaned the mostly bare case, I recommend you change the shift shaft seal, kick down connector O-ring, and rear case bushing.
  
 
Pictured here is a tool that allows removing the shift shaft seal without removal of the parking linkage. It is relatively inexpensive and can be used without pan removal with the transmission in the car.
 
Pictured here is a tool that allows removing the shift shaft seal without removal of the parking linkage. It is relatively inexpensive and can be used without pan removal with the transmission in the car.
Line 143: Line 16:
  
 
[[file:Shift_seal_tool.jpg]]
 
[[file:Shift_seal_tool.jpg]]
 
+
<br><br>
  
 
===Main case bushing replacement===
 
===Main case bushing replacement===
Line 167: Line 40:
  
  
The total thickness of the bearing as compared to the thrust and selective is very close, it is usually about 0.150" (#25 bit, 0.1495").   
+
The total thickness of the bearing as compared to the thrust and selective is very close, it is usually about 0.150" .   
  
 
[[file:Rear-bearing-measure.jpg]]
 
[[file:Rear-bearing-measure.jpg]]
  
It is best to adjust rear endplay on the tight side. On a T-400 (unless it has straight cut planetary gears) the planets will try to thrust load against the case bearing and the center support.
+
It is best to adjust rear end play on the tight side. On a T-400 (unless it has straight cut planetary gears) the planets will try to thrust load against the case bearing and the center support.
 
+
  
 
===Rear planetary setup===
 
===Rear planetary setup===
Line 199: Line 71:
 
Once the intermediate apply piston and the return springs, guide, retainer plate and snap ring is installed, you must install the center support to direct drum sealing rings.
 
Once the intermediate apply piston and the return springs, guide, retainer plate and snap ring is installed, you must install the center support to direct drum sealing rings.
  
There are 3 choices here.
+
*There are three choices here, shown below:
 
+
#Solid teflon is on the left
Solid teflon is on the left, then scarf cut teflon, then cast iron.
+
#Scarf cut teflon, center
 +
#Cast iron, right
  
 
[[file:Seal_rings_t-400.jpg]]
 
[[file:Seal_rings_t-400.jpg]]
  
*Cast iron is what most kits will contain, and what was used stock in most T-400's. Cast iron is the easiest and will work fine for most applications but if using any type of valve body that will not require a modulator teflon is best as it will prevent wear on the direct drum.
+
*Cast iron is what most kits will contain, and what was used stock in most TH400 transmissions. Cast iron is the easiest and will work fine for most applications but if using any type of valve body that will not require a modulator teflon is best as it will prevent wear on the direct drum.
*Scarf cut teflon was used on later model T-400's.
+
*Scarf cut teflon was used on later models of the T-400.
*Solid teflon is used on 4L80s and is interchangeable. I prefer solid teflon, although it is the most time consuming type. If using teflon, be sure there are no burrs on the center support ring grooves. Installing the teflon rings requires a protector to prevent cutting or gouging them, and a sizing device.
+
*Solid teflon is used on the 4L80 series and is interchangeable. I prefer solid teflon, although it is the most time consuming type. If using teflon, be sure there are no burrs on the center support ring grooves. Installing the teflon rings requires a protector to prevent cutting or gouging them, and a sizing device.
  
It helps to heat the rings in hot water before installing so that they will stretch easier. I use a piece of plastic (from a paint can cap) that is cut to size to install and size the rings. Leave it on until you are ready to install the direct drum.
+
It helps to heat the rings in hot water before installing so that they will stretch easier. A piece of plastic (from a paint can cap) that is cut to size can be used to install and size the rings. Leave it on until you are ready to install the direct drum.
  
Notice I left one sealing ring off, 2nd from top groove. This groove separates the direct (3rd gear) and reverse feeds from each other. When dual feeding the directs (as done in this build), this sealing ring is not necessary. Dual feeding the directs on a T-400 will be covered in more depth in another section.
+
One sealing ring has been left off, 2nd from top groove. This groove separates the direct (3rd gear) and reverse feeds from each other. When dual feeding the directs (as done in this build), this sealing ring is not necessary. Dual feeding the directs on a TH400 will be covered in more depth in another section.
  
 
[[File:Center_support_rings.jpg]]
 
[[File:Center_support_rings.jpg]]
Line 226: Line 99:
 
   
 
   
  
Pictured is a late style reaction carrier and an early style. I believe the early style was only used on 1964-1966 models. Notice the actual sprag type element used on the early style on the right. I prefer these types for high HP transbrake builds although not mandatory.
+
Pictured is a late style reaction carrier (left) and an early style. I believe the early style was only used on 1964-1966 models. Notice the actual sprag-type element used on the early style on the right. I prefer these types for high HP transbrake builds although not mandatory. Early style reaction carrier is also found in some HD versions of the THM400 used in medium duty Chevrolet/GMC trucks and the 1991-up 4L80E.  
  
 
[[file:planets.jpg]]
 
[[file:planets.jpg]]
  
  
My "compressor/sizer" for the sealing rings. Radiator hose with band type clamp. You also use a soda pop aluminum can section. Be careful- the thin metal can cut the teflon rings and fingers.
+
My "compressor/sizer" for the sealing rings. Radiator hose with band-type clamp. You also use a soda pop aluminum can section. Be careful- the thin metal can cut the teflon rings and fingers.
  
 
[[file:Center-support-compress.jpg]]
 
[[file:Center-support-compress.jpg]]
Line 243: Line 116:
  
  
You will install the rear thrust bearing into the case or the stock selective spacer in the case with the stock thrust bearing on the rear planet (using assembly gel, petroleum jelly, or grease to hold in place).
+
You will install the rear thrust bearing into the case or the stock selective spacer in the case with the stock thrust bearing on the rear planet (using assembly gel or petroleum jelly to hold in place).
 
You will also install the low/reverse (rear) band.
 
You will also install the low/reverse (rear) band.
 
If required you install the fretting snap ring into the case. ATSG covers when this is necessary, most later model ('71-up?) transmissions have this.
 
If required you install the fretting snap ring into the case. ATSG covers when this is necessary, most later model ('71-up?) transmissions have this.
Line 264: Line 137:
  
  
Once the assembly is seated in the case, be sure the feed holes in the valve body area line up properly, the rear band apply is in the correct location.
+
Once the assembly is seated in the case, be sure the feed holes in the valve body area line up properly, and that the rear band apply is in the correct location.
  
 
Install the center support bolt finger tight, then install the beveled case ring with the gap at the 9 o'clock position.
 
Install the center support bolt finger tight, then install the beveled case ring with the gap at the 9 o'clock position.
Line 275: Line 148:
  
 
[[file:T-400_intermed_clutch.jpg]]
 
[[file:T-400_intermed_clutch.jpg]]
 
  
 
===Sprag design comparison===
 
===Sprag design comparison===
The next picture shows a common roller clutch style drum and a roller clutch on the left, most T-400's will use this style drum. Early units, pre-'71, will have the smooth inner race style drum on the right. 4L80E's also use the "early" style drum and an actual sprag. The stock 16 element sprag is in the center, with the 34 element on the right.
+
The next picture shows a common roller clutch style drum and a roller clutch on the left, most TH400 use this style drum. Early units, pre-'71, will have the smooth inner race style drum on the right. 4L80E's also use the "early" style drum and an actual sprag. The stock 16 element sprag is in the center, with the 34 element on the right.
  
The 4L80E direct drum uses a sprag race that is .045 to .050 wider than the T-400 sprag race. If you acquire a 4L80E direct drum be sure to have the correct race too.
+
The 4L80E direct drum uses a sprag race that is 0.045 to 0.050 wider than the TH400 sprag race. If you acquire a 4L80E direct drum be sure to have the correct race, too.
  
 
+
[[File:Sprag-drum-compare.jpg|thumb|300px|left|TH400 roller clutch and early design sprag unit]] <br style="clear:both"/>
 
+
[[File:Sprag-drum-compare.jpg|thumb|300px|left|T-400 roller clutch and early design sprag unit]] <br style="clear:both"/>
+
  
 
===Spiro loc retainer===
 
===Spiro loc retainer===
 
 
This is a picture of an upgrade for high RPM applications, it is a spiro lock type retainer instead of a regular snap ring. The regular snap rings will release due to centrifugal forces at high RPM. This fits on the direct drum plate that covers the sprag.
 
This is a picture of an upgrade for high RPM applications, it is a spiro lock type retainer instead of a regular snap ring. The regular snap rings will release due to centrifugal forces at high RPM. This fits on the direct drum plate that covers the sprag.
 
 
  
 
[[file:Spirolock.jpg]]
 
[[file:Spirolock.jpg]]
Line 301: Line 168:
 
In the direct drum, leave out the center lip seal. This is the "dual feed" modification you read about.  
 
In the direct drum, leave out the center lip seal. This is the "dual feed" modification you read about.  
  
[[File:Th400centerseal.jpg|thumb|300px|left|T-400 direct drum, left center seal out]] <br style="clear:both"/>
+
[[File:Th400centerseal.jpg|thumb|300px|left|TH400 direct drum, center seal left out; check ball circled]] <br style="clear:both"/>
 +
 
  
 
Notice the circle around the check ball in the aluminum piston. Each drum and piston assembly must have one of these check balls. The check ball may be in the piston, it may be in the drum as circled in the drum photo.
 
Notice the circle around the check ball in the aluminum piston. Each drum and piston assembly must have one of these check balls. The check ball may be in the piston, it may be in the drum as circled in the drum photo.
  
[[File:T-400_direct_piston2.jpg|thumb|300px|left|T-400 piston check ball location]] <br style="clear:both"/>
+
[[File:T-400_direct_piston2.jpg|thumb|300px|left|TH400 piston check ball location]] <br style="clear:both"/>
  
You must install a full set of returns springs in the direct drum. Ignore the experts or online information to leave springs out of the direct drum. If you have a set of heavy duty return springs from a kit or supplier, install half HD springs with half OEM springs. This helps to avoid residual oil behind the piston from forcing the piston out at high RPM when in 1st or 2nd gears.
 
  
 +
You must install a ''full'' set of returns springs in the direct drum. Ignore the experts or online information to leave springs out of the direct drum. If you have a set of heavy duty return springs from a kit or supplier, install half HD springs with half OEM springs. This helps to avoid residual oil behind the piston from forcing the piston out at high RPM when in 1st or 2nd gears.
 +
 +
[[File:T-400_direct_piston.jpg|thumb|300px|left|TH400 piston with springs]] <br style="clear:both"/>
 +
 +
 +
===Clutch pack clearances===
 +
*Direct and forward clutch drums:
 +
0.050" to 0.080" in each drum works well with 5 frictions.
 +
 +
Typically the thicker steel plates are used in the direct clutch drum. These can be mixed with thinner steels used in forward drum when setting clearance.
 +
Try to maintain thicker steels in the direct clutch drum.  Thicker steels take the heat of shifting better.
 +
 +
*Intermediate clutch pack:
 +
0.040" to 0.060" clearance in the intermediate clutch with 3 frictions.
 +
Always use a thicker snap ring 0.095"-0.100" to retain the pressure plate.
 +
 +
===Full manual shift modifications===
 +
FULL manual shifts means just that. You must move the shifter for every shift up or down. NO Automatic shifts.
 +
 +
There are two steel governor fluid tubes out the rear of the main valve body. Remove these tubes. Plug the holes in valve body. 3/8-16 tap and set screws work. Use a liquid thread locker like Loctite.
 +
 +
[[image:Gov_tube_holes.jpg]]
 +
 +
 +
A new 0.110" (#35 or 7/64" bit) hole needs to be drilled in the proper place to loop the governor fluid. Check photos here for location.
 +
 +
[[file:T-400_full_manual_loop03.jpg]]
 +
 +
 +
You must also modify the 1-2 shift valve as listed below for FULL manual shift conversion:
 +
 +
The T-400 has a over-ride shift that will shift out of low gear even if you have manually selected low. It was designed to prevent engine damage.
 +
You can eliminate this feature by performing the following modifications to the valve body.
 +
 +
You must remove the 1-2 shift valve and grind two flats on the land designated by the arrow.
 +
You must plug the exhaust hole in the valve body also designated.
 +
 +
[[file:1-2_shift_valve.jpg]]
 +
 +
Simply grind two flats on the shift valve and deburr them.
 +
You can plug the hole with a brass dowel or a check ball. To use a check ball you will have to first drill the hole larger and then drive the check ball in place.
 +
 +
 +
Drill the marked holes to .125" (1/8") for street use.  At the 1-2 shift hole location (designated #2), drill the small hole out.
 +
 +
For a heavy duty application: 3rd gear shift use a .150" drill (#25 bit, .149) and leave the 1-2 check ball out. '''Caution:''' A 34 element sprag needs to be used with the 1-2 check ball removed. 
 +
 +
Near the bottom of the separator plate in photo, the hole in the round black circle (designated 'Dual Feed') should be plugged when the dual feed modifications are performed with the center lip seal removed from the direct clutch drum.
 +
 +
[[file:T-400_feed_holes03.jpg]]
 +
 +
 +
Another mod is blocking the 2-3 accumulator. I do this with a set screw. You tap the hole and install the set screw available from any hardware store. You will remove the 2-3 accumulator piston, discard the spring.  This firms up the 2-3 shift. 
 +
 +
Re-Install the piston in the hole.  Do not use a plastic piston, they break.
 +
 +
Tap the hole that feed the backside, or spring side, of the accumulator piston. Install the set screw. Re-install the accumulator piston.
 +
 +
What this does is eliminates accumulator function on the 2-3 shift. This results in a very positive 2-3 shift. You could leave 2-3 accumulator function in place and go slightly bigger on the feed hole.
 +
 +
[[file:100_2218-1.jpg]]
 +
 +
===Boost valve modification===
 +
(Full manual shift only)
 +
 +
Modification of the boost valve to have static line pressure and vacuum modulator replaced with aluminum plug. This modification of the boost valve avoids the run away high line pressure in reverse.
 +
 +
Grind a flat spot on the large spool valve land with arrow pointed at it. It is not fussy, 1/4" to 3/8" wide is fine.
 +
 +
[[file:400boost01.jpg]]
 +
 +
 +
Hole location in case to plug. This is shown with the pump removed from the case. This passage must be plugged if boost valve land is ground with flat spot.
 +
 +
[[file:400boost02.jpg]]
 +
 +
 +
Method #2 to plug passage in case: You can remove the valve body and plug the hole shown in photo if pump removal is not going to happen. Perform this method or the method posted above. Both are not needed.
 +
 +
You can slip a 1/4" check ball into the square hole and push it into the round passage at the base of this square hole.
 +
 +
[[file:Block_rev_hole.jpg]]
 +
 +
 +
After the boost valve modification, you can install an aluminum plug that blocks the modulator valve in place. The original bolt and bracket from the vacuum modulator holds the aluminum plug in place.
 +
 +
[[file:T-400_modulator_plug.jpg]]
 +
 +
==Valve body mods, automatic shifts==
 +
The T-400 has a over-ride shift that will shift out of low gear even if you have manually selected low. It was designed to prevent engine damage.
 +
You can eliminate this feature by performing the following modifications to the valve body.
 +
 +
You must remove the 1-2 shift valve and grind two flats on the land designated by the arrow.
 +
You must plug the exhaust hole in the valve body also designated.
 +
 +
[[file:1-2_shift_valve.jpg]]
 +
 +
Simply grind two flats on the shift valve and deburr them.
 +
You can plug the hole with a brass dowel or a check ball. To use a check ball you will have to first drill the hole larger and then drive the check ball in place.
 +
 +
 +
Drill the marked holes in the separator plate to 0.125" (1/8") for street use. At the 1-2 shift hole location (circled #2), drill out the small hole.
 +
 +
For a heavy duty application: 3rd gear shift use 0.150" (#25 bit, 0.1495") drill and leave the 1-2 check ball out. Caution: A 34 element sprag needs to used if the 1-2 check ball is removed.
 +
 +
Near the bottom of the separator plate in photo, the hole in the round black circle (designated 'Dual Feed') should be plugged when the dual feed modifications are performed with the center lip seal removed from the direct clutch drum.
 +
 +
[[file:T-400_feed_holes03.jpg]]
 +
 +
 +
Another modification is blocking the 2-3 accumulator. I do this with a set screw. You tap the hole and install the set screw available from any hardware store. This firms up the 2-3 shift.
 +
 +
Re-install the piston in the bore.  DO NOT use a plastic piston, they break.
 +
 +
[[file:100_2218-1.jpg]]
 +
 +
 +
Next pull out the valve shown below. ''IF'' the spring is on the outer end as shown, remove the spring. This will firm up 1-2 light throttle shifts. For a firmer 1-2 shift, install a small spring on the inside of this valve. The OEM outer spring is too large to fit into the bore first.
 +
 +
[[file:t-400 acc valve.jpg]]
  
[[File:T-400_direct_piston.jpg|thumb|300px|left|T-400 piston with springs]] <br style="clear:both"/>
 
  
 
===Drum installation===
 
===Drum installation===
Then the intermediate clutch stack is assembled into the case on top of the center support. There is a snap ring that goes in the case above the pressure plate pictured. The splined case lugs here in the case are one of the weak points of a T-400. High line pressure, harsh shift calibration, and fatigue cause the lugs to break here. TransGo kits contain a heavy snap ring to help this, I use a center support snap ring from a 2004R. Some performance vendors sell a brace that helps prevent case lug breakage.
+
Then the intermediate clutch stack is assembled into the case on top of the center support. There is a snap ring that goes in the case above the pressure plate pictured. The splined case lugs here in the case are one of the weak points of a T-400. High line pressure, harsh shift calibration, and fatigue cause the lugs to break here. TransGo kits contain a heavy snap ring to help this, I use a center support snap ring from a 200-4R. Some performance vendors sell a brace that helps prevent case lug breakage. One of the keys is to keep the T-400 line pressure under 250 psi if possible.
One of the keys is to keep the T-400 line pressure under 250 psi if possible.
+
  
 
This is the direct drum sitting in the case. The sprag race engages the intermediate clutches. If using a valve body with engine braking, be sure you install the intermediate band.
 
This is the direct drum sitting in the case. The sprag race engages the intermediate clutches. If using a valve body with engine braking, be sure you install the intermediate band.
Line 326: Line 311:
  
  
Case is prepared for pump installation.
+
Case is now prepared for pump installation.
  
  
Line 338: Line 323:
 
Photo of the T-400 governor and cover. Note the direction the plastic drive gear teeth. The plastic drive gear can wear out or break. This result in no upshifts since the governor is not rotating.  
 
Photo of the T-400 governor and cover. Note the direction the plastic drive gear teeth. The plastic drive gear can wear out or break. This result in no upshifts since the governor is not rotating.  
  
[[file:T-400_governor.jpg]]
+
[[File:T-400_governor.jpg|thumb|300px|left|T-400 governor with cover]] <br style="clear:both"/>
  
 
==Vacuum modulator==
 
==Vacuum modulator==
 
The vacuum modulator senses vacuum in the intake manifold as an indicator of engine load. As the throttle is opened, vacuum decreases. The modulator on the transmission will raise the main line pressure in the transmission
 
The vacuum modulator senses vacuum in the intake manifold as an indicator of engine load. As the throttle is opened, vacuum decreases. The modulator on the transmission will raise the main line pressure in the transmission
  
[[file:T-350_modulators.jpg|frame|none|Two types of modulators shown. Low vacuum design on left, ID by the black and red strips. It is larger diameter too]]
+
[[File:T-350_modulators.jpg|thumb|300px|left|Two types of modulators shown. Low vacuum design on left, ID by the black and red strips. It also has a larger diameter]] <br style="clear:both"/>
 +
 
 +
==Kickdown wiring==
 +
[[File:TH400 kick down wiring.jpg]]
 +
 
 +
In the diagram above (1969 Camaro), the power is taken at the wiper motor by using a piggyback terminal connector.
 +
 
 +
The kickdown was originally switched either at the accelerator pedal or at the carb throttle linkage, depending on make. A microswitch can be used to trigger the kickdown, or a factory switch can be used. B&M also sells a kit that includes a heavy duty switch and wiring (shown below).
 +
 
 +
[[File:Bm-20297.jpg]]
 +
 
 +
==Line pressure==
 +
<table table border="1" cellpadding="2" cellspacing="0" >
 +
 
 +
<tr><td bgcolor="#CCCCCC" valign="top" width="37%"><font face="Arial">        <b><font face="Arial" size="3">Range</font></b>
 +
 
 +
              </font></td>
 +
 
 +
<td bgcolor="#CCCCCC" valign="top" width="30%"><font face="Arial">            <b><font face="Arial" size="3">Minimum</font></b>
 +
              </font></td>
 +
 
 +
<td bgcolor="#CCCCCC" valign="top" width="33%"><font face="Arial">            <b><font face="Arial" size="3">Maximum</font></b>
 +
 
 +
              </font></td>
 +
 
 +
            </tr>
 +
 
 +
<tr><td bgcolor="#FFFF00" valign="top" width="37%"><font face="Arial"><b><font face="Arial" size="2">Park</font></b></font></td>
 +
 
 +
<td bgcolor="#FFFF00" valign="top" width="30%"><font face="Arial">            <b><font face="Arial" size="2">55-70</font></b>
 +
 
 +
              </font></td>
 +
 
 +
<td bgcolor="#FFFF00" valign="top" width="33%"><font face="Arial">            <b><font face="Arial" size="2">150-175</font></b>
 +
 
 +
              </font></td>
 +
 
 +
            </tr>
 +
 
 +
<tr><td bgcolor="#FFFFFF" valign="top" width="37%"><font face="Arial"><b><font face="Arial" size="2">Reverse</font></b></font></td>
 +
              <td valign="top" width="30%"><font face="Arial">                <b><font face="Arial" size="2">95-150</font></b>
 +
 
 +
              </font></td>
 +
<td valign="top" width="33%"><font face="Arial">                <b><font face="Arial" size="2">235-260</font></b>
 +
 
 +
              </font></td>
 +
 
 +
            </tr>
 +
 
 +
<tr><td bgcolor="#FFFF00" valign="top" width="37%"><font face="Arial"><b><font face="Arial" size="2">Neutral</font></b></font></td>
 +
 
 +
<td bgcolor="#FFFF00" valign="top" width="30%"><font face="Arial">            <b><font face="Arial" size="2">55-70</font></b>
 +
 
 +
              </font></td>
 +
 
 +
<td bgcolor="#FFFF00" valign="top" width="33%"><font face="Arial">            <b><font face="Arial" size="2">150-175</font></b>
 +
 
 +
              </font></td>
 +
 
 +
            </tr>
 +
 
 +
<tr><td bgcolor="#FFFFFF" valign="top" width="37%"><font face="Arial"><b><font face="Arial" size="2">Drive</font></b></font></td>
 +
 
 +
<td valign="top" width="30%"><font face="Arial">                <b><font face="Arial" size="2">70-90</font></b>
 +
 
 +
              </font></td>
 +
 
 +
<td valign="top" width="33%"><font face="Arial">                <b><font face="Arial" size="2">135-165</font></b>
 +
 
 +
              </font></td>
 +
 
 +
            </tr>
 +
 
 +
<tr><td bgcolor="#FFFF00" valign="top" width="37%"><font face="Arial"><b><font face="Arial" size="2">Second</font></b></font></td>
 +
 
 +
<td bgcolor="#FFFF00" valign="top" width="30%"><font face="Arial">            <b><font face="Arial" size="2">135-165</font></b>
 +
 
 +
              </font></td>
 +
 
 +
<td bgcolor="#FFFF00" valign="top" width="33%"><font face="Arial">            <b><font face="Arial" size="2">135-165</font></b>
 +
 
 +
              </font></td>
 +
 
 +
            </tr>
 +
 
 +
<tr><td bgcolor="#FFFFFF" valign="top" width="37%"><font face="Arial"><b><font face="Arial" size="2">Low</font></b></font></td>
 +
 
 +
<td valign="top" width="30%"><font face="Arial">                <b><font face="Arial" size="2">135-165</font></b>              </font></td>
  
==Resources==  
+
<td valign="top" width="33%"><font face="Arial"><b><font face="Arial" size="2">135-165</font></b></font></td></tr></table><br>
*Original Hotrodders forum thread by jakeshoe, titled [http://www.hotrodders.com/forum/t-400-build-tips-photos-145318.html ''T-400 Build Tips with Photos''].
+
  
 +
'''Note:''' Line pressure fitting is located on driver side of transmission close to shift lever.
  
[[Category:Transmission]]
+
==Transfer case info==
[[Category:good articles]]
+
There are three different output shaft lengths for NP transfer case applications.
 +
Adapter, transfer case, and output shaft length must all match.
 +
;Output shaft lengths (from the back of the case to the end of the shaft):
 +
Output shaft lengths (from the back of the case to the end of the shaft)...
 +
*T-400 to NP203 = 1-3/8" (1.1" adapter)
 +
*T-400 to late NP205/NP208 = 2-1/2"
 +
*T-400 to early NP205 = 4-1/2" (same as short 2WD shaft)

Latest revision as of 17:16, 18 August 2023

Personal tools
Namespaces
Variants
Actions
Navigation
Categories
Toolbox