Quadrajet

Jump to: navigation, search
(Add image)
(Clean up; format; add text, link)
Line 1: Line 1:
 
{{copyright}}
 
{{copyright}}
 
==Overview==
 
==Overview==
The '''Quadrajet''' is a 4 barrel [[carburetor]] made by the [[Rochester Products Division]] of GM that was first used on the Chevrolet 396 Mark IV engine in 1965 then widely used on [[General Motors]] motor vehicles until 1990.  Its last application was on the [[Oldsmobile V8 engine#307|Oldsmobile 307]] V8 engine, which was last used in the [[Cadillac Brougham]] and full size [[station wagons]] made by [[Chevrolet]], [[Pontiac]], [[Oldsmobile]], and [[Buick]]. Not widely known, the Q-jet was used briefly by Ford on the 1971 429 Cobra Jet and was also used by Mopar on their 360 truck engines in the '80's.  
+
The '''Quadrajet''' is a 4 barrel carburetor made by the Rochester Products Division of GM that was first used on the Chevrolet 396 Mark IV engine in 1965 then widely used on General Motors motor vehicles until 1990.  Its last application was on the Oldsmobile 307 V8 engine, which was last used in the Cadillac Brougham and full size station wagons made by Chevrolet, Pontiac, Oldsmobile, and Buick. Not widely known, the Q-jet was used briefly by Ford on the 1971 429 Cobra Jet and was also used by Mopar on their 360 truck engines in the '80s.  
  
The Quadrajet has been described as one of the best carburetors made for passenger vehicles, offering the best compromise of [[Fuel economy in automobiles|fuel economy]], performance, driveability, and [[automobile emissions control]].{{Fact|date=July 2007}}
+
The Quadrajet has been described as one of the best carburetors made for passenger vehicles, offering the best compromise of fuel economy, performance, driveability, and emissions control.
[[File:Q-JET 750 TO 800 CFM VENTURI COMPARISON.jpg|thumb|100px|Comparison of 750 cfm and 800 cfm Q-jet primary venturi/throttle bores.]]
+
[[File:Q-JET 750 TO 800 CFM VENTURI COMPARISON.jpg|thumb|300px|Comparison of 750 cfm and 800 cfm Q-jet primary venturi/throttle bores.]]
  
 
==Basic design==
 
==Basic design==
The Quadrajet is a "spread bore" carburetor; the primary [[venturi]]s are much smaller than the secondary venturis, and the center to center spacing of the throttle bores are different, primary to secondary. By comparison, a "square bore" carburetor may have primary and secondary venturis of similar if not exactly the same size and the center to center spacing of the primaries and secondaries are the same, thus the name "squarebore".   
+
The Quadrajet is a "spread bore" carburetor; the primary venturis are much smaller than the secondary venturis, and the center to center spacing of the throttle bores are different, primary to secondary. By comparison, a "squarebore" carburetor may have primary and secondary venturis of similar if not exactly the same size and the center to center spacing of the primaries and secondaries are the same, thus the name "squarebore".   
  
Most Quadrajets made prior to 1976 were capable of 750 [[cubic feet per minute]] (CFM) maximum air flow measured at a 1.5"/Hg pressure drop, but some were manufactured as 800 (and larger, in isolated cases like the '71 Pontiac H.O., more below) CFM. The increase in airflow was due to a larger primary venturi. This was first done in 1971 by the Pontiac and Buick division of GM for use on their 455 cid/high performance engines.  
+
Most Quadrajets made prior to 1976 were capable of 750 cubic feet per minute (CFM) maximum air flow measured at a 1.5"/Hg pressure drop, but some were manufactured as 800 CFM (and larger, in isolated cases like the '71 Pontiac H.O., more below). The increase in airflow was due to a larger primary venturi. This was first done in 1971 by the Pontiac and Buick division of GM for use on their 455 cid/high performance engines.  
  
 
In 1971 Pontiac had designed a special Q-jet that had the most flow of any production Q-jet, but because the modification decreased the vacuum signal on the primary side too much it was discontinued, so it was a "one year wonder" that fetches outrageous prices from restorers today. Many more 800 cfm Q-jets were installed from 1976-up. One way to locate a large casting carb is to source one from an '80-up light truck. Even the Chevy/GMC 4.3L V6 trucks used the large casting 800 cfm Q-jet!
 
In 1971 Pontiac had designed a special Q-jet that had the most flow of any production Q-jet, but because the modification decreased the vacuum signal on the primary side too much it was discontinued, so it was a "one year wonder" that fetches outrageous prices from restorers today. Many more 800 cfm Q-jets were installed from 1976-up. One way to locate a large casting carb is to source one from an '80-up light truck. Even the Chevy/GMC 4.3L V6 trucks used the large casting 800 cfm Q-jet!
[[File:ANEROID OR FILLER SPOOL DETAILS.jpg|thumb|300px|Early APT, ca. 1975]]
+
[[File:ANEROID OR FILLER SPOOL DETAILS.jpg|thumb|400px|Early APT, ca. 1975]]
  
 
==Power enrichment==
 
==Power enrichment==
Most Quadrajets use a vacuum operated piston (the "power piston" or "PP") to move the primary metering rods to control the air/fuel ratio, allowing the mixture to be lean under low load/high vacuum conditions and rich during high load/low vacuum conditions.  A less-common, early version uses a linkage driven off the primary throttle shaft to mechanically move the power piston.  There were also two Q-jet designs used mainly in 1975 only, that used an auxiliary enrichment system in addition to the primary PP system. There are two types of auxiliary systems: one has an aneroid "bellows" that responds to barometric pressure changes; it used no vacuum or power piston to operate it. The other uses a vacuum operated PP like the primary PP, but it differs by using only one metering rod and one jet to feed both sides of the primaries. These were abandoned soon after they were released; it was found the primary PP system could be tailored to meet the requirements without the added complexity of the auxiliary system. Other changes came on-line in that same era, info on this can be seen at [[Quadrajet#Variants|Variants]].  
+
Most Quadrajets use a vacuum operated "power piston" (or "PP") to move the primary metering rods to control the air/fuel ratio, allowing the mixture to be leaner under low load/high vacuum conditions and richer during high load/low vacuum conditions.  A less-common, early version uses a linkage attached to the primary throttle shaft to mechanically move the power piston.   
 +
 
 +
There were also two additional Q-jet designs used mainly in 1975 only, that used an auxiliary enrichment system in addition to the primary PP system. There are two types of auxiliary systems: one has an aneroid "bellows" that responds to barometric pressure changes; it used no vacuum or power piston to operate it. The other uses a vacuum operated PP like the primary PP, but it differs by using only one metering rod and one fixed jet to feed both sides of the primaries. These were abandoned soon after they were released; it was found the primary PP system could be tailored to meet the requirements without the added complexity of the auxiliary system. Other changes came on-line in that same era, info on this can be seen at [[Quadrajet#Variants|Q-jet variants]].  
  
 
[[File:Qjet with CCC.jpg|300px|thumb|left|1981-up Q-jet with CCC emissions/computer control]]  
 
[[File:Qjet with CCC.jpg|300px|thumb|left|1981-up Q-jet with CCC emissions/computer control]]  
Line 32: Line 34:
 
==Drawbacks==
 
==Drawbacks==
 
Significant negative features of the Quadrajet were:
 
Significant negative features of the Quadrajet were:
# Its leaky fuel bowl. As in nearly all carburetors, the Quadrajet bowl had pressed-in plugs used to seal holes left after drilling fuel passages during the manufacturing of the carburetor.  These plugs in the Q-jet sometimes leaked fuel causing: (a) a cold engine being hard to start, (b) erratic idling, (c) poor fuel mileage, and (d) excessive emissions.  Many Quadrajets have their fuel bowl plugs sealed with [[epoxy]] when rebuilt to prevent leaks. This may be good for a short time but epoxy will not stand up to the extreme conditions encounterd for long. Fortunately, leaking well plugs is primarily a problem only on the first few years of production when pressed in cup plugs were used instead of the later (and better) spun-in aluminum plugs that were swaged in place.  
+
* Leaking fuel bowl. As in nearly all carburetors, the Quadrajet float bowl has pressed-in plugs used to seal holes left after drilling fuel passages during the manufacturing of the carburetor.  These plugs in the Q-jet sometimes leaked fuel causing:  
# The very small float bowl/fuel chamber can result in fuel starvation in extreme high-performance situations, but can usually be traced to a fuel delivery problem to the carburetor, such as a worn fuel pump, pump push rod, or camshaft eccentric. In normal driving and mild performance use it provides excellent control of fuel level.
+
** cold engine being hard to start
# The fuel inlet/fuel filter housing threads tend to be very fragile.  It is common for the fuel inlet threads in the main casting to strip.  There are several "fixes" available in the aftermarket:  New oversize self-tapping [[fuel filter]] housings; new fuel filter housings that seal with [[O-rings]]; and [[Heli-Coil]] rethreading kits.
+
** erratic idling
# Almost all Quadrajets today have some amount of warpage of the castings.  The root cause of this warpage is over-tightening the front two carburetor mounting bolts, often in combination with a base gasket that doesn't have hard [[nylon]] inserts for the bolt holes.
+
** poor fuel mileage
# The steel primary throttle shaft will tend to wear the aluminum casting material.  This results in an air leak and in extreme cases could cause the primary throttle blades to not close properly. This results in poor idle quality.  The [[aftermarket]] has responded; several vendors are supplying bushing repair kits for the Q-jet throttle body.
+
** excessive emissions  
 +
:Fortunately, leaking well plugs is primarily a problem only on the first few years of production when pressed in cup plugs were used instead of the later (and better) spun-in aluminum plugs that were swaged in place. Many Quadrajets have their fuel bowl plugs sealed with epoxy when rebuilt to prevent leaks. This may be good for a short time but epoxy will not stand up to the extreme conditions (heat and fuel contact) encountered for long.  
 +
* The small float bowl can result in fuel starvation in extreme high-performance situations, but can usually be traced to a fuel delivery problem to the carburetor, such as a worn fuel pump, pump push rod, or camshaft eccentric. In normal driving and even off road performance use it provides excellent control of the fuel level.
 +
* The fuel inlet/fuel filter housing threads tend to be very fragile.  It is common for the fuel inlet threads in the main casting to strip.  There are several "fixes" available in the aftermarket:  New oversize self-tapping fuel filter housings; new fuel filter housings that seal with O-rings; and Heli-Coil rethreading kits.
 +
* Almost all Quadrajets today have some amount of warpage of the castings.  The root cause of this warpage is often over-tightening the front two carburetor mounting bolts, often in combination with a base gasket that doesn't have hard nylon inserts for the bolt holes. Without the inserts the base gasket can compress, warping the castings.
 +
* The steel primary throttle shaft will tend to wear the aluminum casting material.  This results in an air leak and in extreme cases could cause the primary throttle blades to not close properly. This can result in poor idle quality and unfiltered air to be pulled into the engine.  The aftermarket has responded; several vendors are supplying bushing repair kits for the Q-jet throttle body.
  
==Variants==
+
==Q-jet variants==
A major change to the Quadrajet was implemented for the 1975 model year.  These newer carburetors are considered "Modified Quadrajets" or "Mod Quads".  In addition to the casting revisions that result in a physically larger carburetor, the primary metering rod length is different from '74 and older Q-Jets.  They were also equipped with a self contained choke mechanism that no longer relied on an intake manifold mounted choke, and a number "1" was added to the beginning of their identification numbers.  
+
A major change to the Quadrajet was implemented for the 1975 model year.  These newer carburetors are considered "Modified Quadrajets" or "Mod Quads".  In addition to the casting revisions that resulted in a somewhat physically larger carburetor, the primary metering rod length is different (shorter) than those from '74 and older Q-jets.  They were also equipped with a self-contained choke mechanism that no longer relied on a choke coil mounted on the intake manifold above the heat crossover port. Also the number "1" was added to the beginning of their identification numbers.  
  
Quadrajet carburetors were also built under contract by [[Carter]].  This seems to have happened at times when Rochester's facility could not keep up with demand.  Carter-built Quadrajets will have the name "Carter" cast into them, but are functionally identical to the Rochester-built equivalent.  The "newest" Q-Jets to be made were built for, and sold by [[Edelbrock]].  There were several versions made, for both stock replacement and "performance" applications.  One version was specifically intended as a replacement for Carter Thermoquad carburetors.  The Edelbrock Q-Jet carbs have been discontinued, although at this time Edelbrock still supplies some tuning and replacement parts. [[Quadrajet#Power enrichment|Return to top]]
+
Quadrajet carburetors were also built under contract by Carter.  This seems to have happened at times when Rochester's facility could not keep up with demand.  Carter-built Quadrajets will have the name "Carter" cast into them, but are functionally identical to the Rochester-built equivalent.  The "newest" Q-jets to be made were built for, and sold by Edelbrock.  There were several versions made, for both stock replacement and "performance" applications.  One version was specifically intended as a replacement for Carter Thermoquad carburetors.  The Edelbrock Q-jet carbs have been discontinued, although at this time Edelbrock still supplies some tuning and replacement parts. [[Quadrajet#Power enrichment|Return to top]]
  
 
===So, all Q-jets are the same, right?===   
 
===So, all Q-jets are the same, right?===   
 
 
Not hardly! These are a few differences:
 
Not hardly! These are a few differences:
  
Line 64: Line 70:
 
There are two different length primary rods, there are stepped and tapered rods. The bottom line to this is there are [b]millions[/b] of different combos possible for the '68-up carb alone! And this doesn't even consider all the different linkages, choke pull-offs, the two different CFM ratings, etc., ad infinitum.
 
There are two different length primary rods, there are stepped and tapered rods. The bottom line to this is there are [b]millions[/b] of different combos possible for the '68-up carb alone! And this doesn't even consider all the different linkages, choke pull-offs, the two different CFM ratings, etc., ad infinitum.
  
== Choosing a Carb ==
+
==Choosing a carb==
 
You need to pay attention to a few important things when choosing a carb to rebuild/use on your engine:
 
You need to pay attention to a few important things when choosing a carb to rebuild/use on your engine:
  
 
*Fuel inlet (straight or 90º), so it doesn't interfere w/any of the accessories or water neck, etc.
 
*Fuel inlet (straight or 90º), so it doesn't interfere w/any of the accessories or water neck, etc.
 
*Throttle arm- whether or not it can accommodate the trans you're using. This is important if using a TH350 that needs a "below-the-shaft" hook up point to pull the detent cable.
 
*Throttle arm- whether or not it can accommodate the trans you're using. This is important if using a TH350 that needs a "below-the-shaft" hook up point to pull the detent cable.
*Choke type. Most prefer an electric. A hot air type choke can be converted to electric easily.
+
*Choke type. Most prefer an electric. A hot air type choke can be converted to electric easily. A divorced choke Q-jet is able to be converted to electric, however the kit is rather expensive.
  
 
Beyond that, you basically just work w/what you have. The Q-jet is very versatile and will work fine on any number of engines.
 
Beyond that, you basically just work w/what you have. The Q-jet is very versatile and will work fine on any number of engines.
Line 93: Line 99:
  
 
GM p/n 7029922 is a rather weak spring that was OEM for HO Pontiac engines from the early '70's. It delays enrichment until vacuum drops to 3 in/Hg. This spring will work with durations >/= 230 degrees @ 0.050”. Another GM p/n is 7037305 for a PP spring that is set for 6 in/Hg, and would work well w/a high vacuum, smooth idling and/or wide LSA-type cam. Thing is, unless the parts counter guy is cool w/you, they come in packs of 10 springs.
 
GM p/n 7029922 is a rather weak spring that was OEM for HO Pontiac engines from the early '70's. It delays enrichment until vacuum drops to 3 in/Hg. This spring will work with durations >/= 230 degrees @ 0.050”. Another GM p/n is 7037305 for a PP spring that is set for 6 in/Hg, and would work well w/a high vacuum, smooth idling and/or wide LSA-type cam. Thing is, unless the parts counter guy is cool w/you, they come in packs of 10 springs.
 
  
 
===Secondary metering hangars and rods===
 
===Secondary metering hangars and rods===
 
 
[[File:Secondary rods 002.jpg|thumb|left|250px]]
 
[[File:Secondary rods 002.jpg|thumb|left|250px]]
 
<br style="clear:both"/>
 
<br style="clear:both"/>
 
  
 
==Intake manifolds==
 
==Intake manifolds==
Line 106: Line 109:
  
 
===Tuning and repair parts===
 
===Tuning and repair parts===
 
+
*[http://www.cliffshighperformance.com/index.html Cliff's High Performance]  
[http://www.cliffshighperformance.com/index.html Cliff's High Performance] <br  />[http://quadrajetparts.com/index.php QuadrajetParts.com] <br  />[http://www.carburetion.com/index.htm Carbs Unlimited] <br  />[http://www.carbkitsource.com/ The Carburetor Doctor]
+
*[http://quadrajetparts.com/index.php QuadrajetParts.com]  
 +
*[http://www.carburetion.com/index.htm Carbs Unlimited]  
 +
*[http://www.carbkitsource.com/ The Carburetor Doctor]
  
 
==References==
 
==References==
Line 113: Line 118:
  
 
==See also==
 
==See also==
Hotrodders Knowledge Base: [http://www.hotrodders.com/kb/carburetor-articles Carburetor articles] - Contains links to various useful carburetor websites and threads.
+
*Crankshaft Coalition wiki [http://www.crankshaftcoalition.com/wiki/Category:Carburetors Carburetor articles]
 
+
*Hotrodders Knowledge Base [http://www.hotrodders.com/kb/carburetor-articles Carburetor articles] - contains links to various useful carburetor websites and threads.
==External links==
+
 
+
  
[[Category:Automotive technology tradenames]]
+
{{youcanedit}}
 
[[Category:Engine]]
 
[[Category:Engine]]
 
[[Category:Carburetors]]
 
[[Category:Carburetors]]

Revision as of 20:06, 21 May 2012

Personal tools
Namespaces
Variants
Actions
Navigation
Categories
Toolbox